Advertisements
In this article, we consider the third-generation Mercury Montego, produced from 2005 to 2007. Here you will find fuse box diagrams of Mercury Montego 2005, 2006 and 2007, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
Fuse Layout Mercury Montego 2005-2007
Cigar lighter (power outlet) fuses in the Mercury Montego are the fuse F9 (Cigar lighter) in the Instrument panel fuse box, and fuse #17 (2005) or #16 (2006-2007) (Power point – Console) in the Engine Compartment Fuse Box.
Table of Contents
Passenger Compartment Fuse Box
Passenger Compartment Fuse Box
Fuse box location
The fuse box is located under the dashboard, on the driver’s side.
Fuse box diagram
Advertisements
Assignment of the fuses in the passenger compartment
| № | Protected components | Amp |
|---|---|---|
| F1 | High beams | 20 |
| F2 | Interior lamps (Courtesy and demand lamps), Delayed accessory (Power windows and moonroof) | 15 |
| F3 | Access/Security (Power door lock actuators, Decklid lock actuator, Decklid solenoid) | 25 |
| F4 | Adjustable pedal switch | 15 |
| F5 | Horns | 20 |
| F6 | Audio (Subwoofer) | 20 |
| F7 | Power/Keep Alive Memory (KAM): Cluster and Powertrain Control Module (PCM), Climate control, Analog clock | 7.5 |
| F8 | Park lamps, Side markers, Trailer tow protect | 15 |
| F9 | Cigar lighter, Data Link Connector (DLC) | 20 |
| F10 | Mirrors and memory module, SDARS | 7.5 |
| F11 | Audio, Family Entertainment System (FES) | 20 |
| F12 | Back-up lamps, Electrochromatic mirror, Reverse Sensing System (RSS), Trailer tow protect | 10 |
| F13 | Audio | 7.5 |
| F14 | Starter relay coil, PCM | 7.5 |
| F15 | Delayed accessory (Driver window motor logic, Moonroof, Audio, Driver door lock switch illumination) | 10 |
| F16 | Rear defroster indicator, Heated mirrors | 10 |
| F17 | Rear defroster | 30 |
| F18 | PCM relay coil, Shifter Brake-Shift Interlock (BSI), Passive Anti-Theft System (PATS) module, Fuel relay coil, Brake lamps, Center High-Mounted Stop Lamp (CHMSL) | 10 |
| F19 | Anti-lock Brake System (ABS)/Traction control module, All Wheel Drive (AWD) module, RSS, Heated seat modules | 10 |
| F20 | Cluster, Climate control | 7.5 |
| F21 | Restraint Control Module (RCM) | 7.5 |
| F22 | Electrochromatic mirror, Compass module | 7.5 |
| F23 | Wiper relay coil, Blower relay coil, Cluster logic | 7.5 |
| F24 | Occupant Classification Sensor (OCS), Passenger Air bag Deactivation (PAD) | 7.5 |
| C1 | Circuit breaker: Delayed accessory (Front passenger window, Rear passenger windows [via window switch], Window switch illumination, Backlighting | 30 |
Engine Compartment Fuse Box
Engine Compartment Fuse Box
Fuse box location
It is located in the engine compartment (on the driver’s side), under the cover.
Fuse box diagram (2005)
Advertisements
Assignment of the fuses and relays in the engine compartment (2005)
| № | Protected components | Amp |
|---|---|---|
| 1 | SJB, SJB fuses 1, 2, 3, 4, 5, 8 and 12 | 80 |
| 2 | Not used | — |
| 3 | Not used | — |
| 4 | Wiper RUN/ACC relay to PDB, PDB fuses 37 and 38 | 50 |
| 5 | Not used | — |
| 6 | Moonroof | 20 |
| 7 | Not used | — |
| 8 | Engine cooling fan | 60 |
| 9 | Not used | — |
| 10 | Anti-lock Brake System (ABS) (Motor) | 40 |
| 11 | Starter | 30 |
| 12 | Powertrain Control Module (PCM) relay | 30 |
| 13 | ABS (Valves) | 20 |
| 14 | Not used | — |
| 15 | Not used | — |
| 16 | Traction Control Module (TCM) | 15 |
| 17 | Power point (Console) | 20 |
| 18 | Alternator | 10 |
| 19 | Logic feed to SJB, SJB solid state devices | 40 |
| 20 | Right-hand HID low beam headlamp | 20 |
| 21 | Rear defroster | 40 |
| 22 | Power seat motors (passenger) | 30 |
| 23 | Heated seat modules | 30 |
| 24 | Fog lamps | 15 |
| 25 | A/C clutch relay, A/C compressor clutch | 10 |
| 26 | Not used | — |
| 27 | Not used | — |
| 28 | Fuel relay (Fuel pump driver module, Fuel pump) | 15 |
| 29 | SJB power, SJB (Circuit breaker, Fuses 6, 7, 9, 10, 11 and 15) | 80 |
| 30 | Driver window motor | 30 |
| 31 | Left-hand HID low beam headlamp | 20 |
| 32 | Not used | — |
| 33 | Driver seat motors, Memory module | 30 |
| 34 | Ignition switch (to SJB) | 30 |
| 35 | Not used | — |
| 36 | Front A/C blower motor | 40 |
| 37 | Front wiper, Front washer | 30 |
| 38 | Heated Positive Crankcase Ventilation (PCV) valve | 5 |
| 39 | Not used | — |
| 40 | TCM, EVMV, Canister vent, ESM, Exhaust Gas Oxygen heaters, A/C clutch | 10 |
| 41 | PCM, Injectors, Ignition coils, Mass Air Flow (MAF) sensor | 15 |
| 42 | Not used | — |
| 43 | Not used | — |
| 45 | Not used | — |
| 46 | Not used | — |
| Relays | ||
| 47 | Not used | |
| 48 | Fog lamps | |
| 49 | Not used | |
| 50 | Not used | |
| 51 | A/C clutch | |
| 52 | Not used | |
| 53 | Fuel pump driver module, Fuel pump | |
| 54 | Not used | |
| 55 | PCM relay, PDB fuses 40 and 41 | |
| 56 | Starter motor solenoid | |
| 57 | Front A/C blower motor | |
| 58 | Wipers | |
| 59 | Not used | |
| Diodes | ||
| 60 | PCM | |
| 61 | PCM |
Fuse box diagram (2006-2007)
Advertisements
Assignment of the fuses and relays in the engine compartment (2006-2007)
| № | Protected components | Amp |
|---|---|---|
| 1 | SJB, SJB fuses 1, 2, 3, 4, 5, 8 and 12 | 80 |
| 2 | Not used | — |
| 3 | Front wiper, Front washer | 30 |
| 4 | Not used | — |
| 5 | Moonroof | 20 |
| 6 | Not used | — |
| 7 | Engine cooling fan | 60 |
| 8 | Not used | — |
| 9 | Anti-lock Brake System (ABS) (Motor) | 40 |
| 10 | Starter | 30 |
| 11 | Powertrain Control Module (PCM) relay | 30 |
| 12 | ABS (Valves) | 20 |
| 13 | Not used | — |
| 14 | Not used | — |
| 15 | Traction Control Module (TCM) | 15 |
| 16 | Power point (Console) | 20 |
| 17 | Alternator | 10 |
| 18 | Logic feed to SJB, SJB solid state devices | 40 |
| 19 | Right-hand HID low beam headlamp | 20 |
| 20 | Rear defroster | 40 |
| 21 | Power seat motors (passenger) | 30 |
| 22 | Heated seat module | 30 |
| 23 | Fog lamps | 15 |
| 24 | A/C clutch relay, A/C compressor clutch | 10 |
| 25 | Not used | — |
| 26 | Not used | — |
| 27 | Fuel relay (Fuel pump driver module, Fuel pump) | 15 |
| 28 | SJB power, SJB (Circuit breaker, Fuses 6, 7, 9, 10, 11 and 15) | 80 |
| 29 | Driver window motor | 30 |
| 28 | SJB power, SJB (Circuit breaker, Fuses 6, 7, 9, 10, 11 and 15) | 80 |
| 29 | Driver window motor | 30 |
| 30 | Left-hand HID low beam headlamp | 20 |
| 31 | Not used | — |
| 32 | Driver seat motors, Memory module | 30 |
| 33 | Ignition switch (to SJB) | 30 |
| 34 | Not used | — |
| 35 | Front A/C blower motor | 40 |
| 36 | Not used | — |
| 37 | Not used | — |
| 38 | Not used | — |
| 45 | Not used | — |
| 46 | Heated Positive Crankcase Ventilation (PCV) valve | 5 |
| 47 | Not used | — |
| 48 | TCM, EVMV, Canister vent, ESM, Exhaust Gas Oxygen heaters, A/C clutch | 10 |
| 49 | PCM, Injectors, Ignition coils, Mass Air Flow (MAF) sensor | 15 |
| Relays | ||
| 41 | Fog lamps | |
| 42 | Not used | |
| 43 | A/C clutch | |
| 44 | Fuel pump driver module, Fuel pump | |
| 50 | PCM relay, PDB fuses 40 and 41 | |
| 51 | Starter motor solenoid | |
| 52 | A/C blower motor | |
| 53 | Not used | |
| 54 | Not used | |
| 55 | Not used | |
| 56 | Not used | |
| 57 | Front wiper | |
| 58 | Not used | |
| Diodes | ||
| 39 | PCM | |
| 40 | A/C clutch |
Advertisements