Mercury Monterey (2004-2007) fuses and relays

Advertisements

 

The minivan Mercury Monterey was produced from 2004 to 2007. Here you will find fuse box diagrams of Mercury Monterey 2004, 2005, 2006 and 2007, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.

Fuse Layout Mercury Monterey 2004-2007

Cigar lighter (power outlet) fuses in the Mercury Monterey are the fuses #57 (2004: Cigar lighter), #61 (2004: 3rd-row power point), #63 (2005-2007: Instrument panel power point, Cigar lighter) and #66 (2005-2007: 2nd-row seat power point, 3rd row power point) in the Engine Compartment Fuse Box.

Instrument Panel Fuse Box

Fuse box location

The fuse panel is located below and to the left of the steering wheel by the brake pedal.The location of the fuses in the passenger compartment: Mercury Monterey (2004-2007)

Fuse box diagram

Instrument panel fuse box diagram: Mercury Monterey (2004, 2005, 2006, 2007)

Advertisements

 

Assignment of the fuses in the passenger compartment
№Protected componentsAmp
3Front wiper motor Run feed10
4B+ feed to outside mirrors5
5Vent window power feed/Radio feed20
6Driver door switch illumination/Passenger door switch illumination5
7Rear wiper Run feed10
8Cluster/Electronic Automatic Temperature Control (EATC) B+ feed, DVD10
9Passive Anti-theft System (PATS) LED feed10
10Auxiliary radio5
11Auxiliary climate control system/Power Liftgate Module/Left and right power sliding door module/Data Link Connector (DLC)/Clock B+ feeds5
12Brake-Shift Interlock (BSI) Run feed, Climate control system Run feed5
13Compass/Driver heated seat/Passenger heated seats/Reverse sensing system/Power Liftgate Module/Power sliding door Run feeds5
14Underhood fuse box Run feed, Front blower Run feed5
15Brake On-Off (BOO) switch B+10
16Steering angle/Cluster/Power sliding door and power liftgate inhibit LED/Electrochromatic mirror Run/Start/Tire Pressure Monitoring System (TPMS)5
17Restraint Control Module (RCM)/Passenger Air bag Disable Indicator (PADI)/Passenger Occupant Detection System (PODS) Run/Start10
18Anti-lock Brake System (ABS) module/Brake pressure switch/Speed control Run/Start10
19PATS/Cluster/Air bag LED/Powertrain Control Module (PCM) relay Run/Start5
20Liftgate Start feed, Radio Start feed10
21Starter relay power START10
Relays
1Accessory delay relay 1
2Accessory delay relay 2

Engine Compartment Fuse Box

Fuse box location

The fuse box is located in the engine compartment (on the driver’s side), under the coverThe location of the fuses in the engine compartment: Mercury Monterey (2004-2007)

Fuse box diagram

Under-hood fuse box diagram: Mercury Monterey (2004, 2005, 2006, 2007)

Advertisements

 

Assignment of the fuses and relays in the engine compartment
№Protected componentsAmp
1Not used—
2Right cooling fan30
3Left cooling fan30
4Starter solenoid30
5Right-hand power sliding door30
6SJB accessory #2 (driver power window)30
7Auxiliary blower motor30
8Anti-lock Brake System (ABS) #2 (coil power)40
9Power liftgate30
10SJB accessory #1 (passenger window, radio, vent windows)30
11Left power seat/heated seat30
12ABS #1 (pump motor)40
13Rear defroster40
14Front climate control system blower motor30
15Right power seat/heated seat30
16Left-hand power sliding door30
40Engine #1 (A/C relay coil, IMRC, HEGO sensors, Canister purge, Transmission module, Canister vent (2004-2005))15
41Horn25
42A/C clutch10
43Engine #2 (Cooling fan relays, Injectors, PCM, MAF sensor, IAC, Ignition coil, ESM)15
44Heated PCV10
45High beams15
46Trailer stop/turn lamps20
47Fuel pump, Fuel pump shut-off switch15
48Fog lamps15
49PCM KAP, Canister vent (2006-2007)10
50Alternator10
51Adjustable pedals (non-memory) or memory module10
52Trailer tow park lamps20
53Heated mirrors10
54Front wiper motor30
55Rear wiper motor25
56Premium sound radio30
572004: Cigar lighter20
58SJB #1 - Center High-Mounted Stop Lamp (CHMSL), License plate lamps, OBD II, Dome lamp, Auxiliary blend doors, Switch illumination (feeds F-8, F-9, F-10nd F-ll)30
59Radio (non-premium)20
60SJB #4 - Back-up lamps, Theft sounder (2004), Door locks30
612004: 3rd row power point20
62SJB #3 - Right comering/auxiliary lamps, Right low beam, Left front park/turn lamps, Left rear park/stop/turn lamps, Instrument panel courtesy lamps, Step well lamps, Left signal mirror, Clock, Cluster, Message center (SJB F-15), Switch illumination for: overhead console, DVD/Rear climate control system, Headlamp switch illumination, Climate control illumination30
63Instrument panel power point, Cigar lighter (2005-2007)20
64Ignition switch #1 feed20
65SJB #2 - Left cornering/auxiliary lamps, Left low beam, Right front park/turn lamps, Right rear park/stop/turn lamps, Puddle lamps, Mirror signals, Visors, 2nd and 3rd row lamps, Cargo lamp, Defroster indicator30
662nd row seat power point, 3rd row power point (2005-2007)20
67Ignition switch #2 feed20
70Not used—
71Not used—
72Not used—
73Not used—
74Not used—
Relays
20Powertrain Control Module (PCM) power
21Horn
22A/C clutch
23High beams
24Starter
25Fuel pump
26Fog lamps
27Not used
28Auxiliary blower
29Trailer park lamps
30Left trailer stop/turn lamps
31Right trailer stop/turn lamps
32Rear defroster
Diodes
75PCM
76A/C clutch

Advertisements

Auxiliary relay box (cooling fans)

The relay box is located in the engine compartment by the radiator.

Auxiliary relay box: Mercury Monterey (2004, 2005, 2006, 2007)

Auxiliary Relay Box
№Protected componentsAmp
6Right-hand cooling fan motor (Vehicles with trailer tow package only)40
7Low-speed cooling fan circuit breaker (Vehicles with trailer tow package only)15
8Left-hand cooling fan motor (Vehicles with trailer tow package)40
8Low-speed cooling fan circuit breaker (Vehicles without trailer tow package)10
Relays
1Cooling fan relay #1 or #4
2Cooling fan relay #2 or #5
3Cooling fan relay #3
4Cooling fan relay #4 or #1
5Cooling fan relay #5 or #2
Learn more:

How to check the fuses?

How to replace a blown fuse?

Why do car fuses blow?

Types of automotive fuses

Advertisements