X

Chevrolet Malibu (2004-2007) fuses and relays

Advertisements

 

In this article, we consider the sixth-generation Chevrolet Malibu, produced from 2004 to 2007. Here you will find fuse box diagrams of Chevrolet Malibu 2004, 2005, 2006 and 2007, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.

Fuse Layout Chevrolet Malibu 2004-2007


Cigar lighter (power outlet) fuses in the Chevrolet Malibu are the fuses №12 (Auxiliary Power 2) and №20 (Cigarette Lighter, Auxiliary Power Outlet) in the Luggage Compartment Fuse Box.


Passenger Compartment Fuse Box

Fuse box location

It is located on the passenger side of the vehicle, on the lower portion of the instrument panel near the floor, behind the cover.

Fuse box diagram

Advertisements

 

Assignment of the fuses and relays in the Passenger Compartment
NameUsage
POWER MIRRORSPower Mirrors
EPSElectric Power Steering
RUN/CRANKCruise Control, Electronic Range Select, Driver Shift Control, Passenger Airbag Status Indicator
HVAC BLOWER HIGH (Relay)Climate Control System
CLUSTER/ THEFTInstrument Panel Cluster, Theft Deterrent System
ONSTAROnStar System
NOT INSTALLEDNot Used
AIRBAG (IGN)Airbag System
HVAC CTRL (BATT)Climate Control System
PEDALAdjustable Throttle and Brake Pedal
WIPER SWWindshield Wiper/Washer Switch
IGN SENSORIgnition Switch
STR/WHL ILLUMSteering Wheel Controls Backlighting
NOT INSTALLEDNot Used
RADIOAudio System
INTERIOR LIGHTSOverhead Lighting, Trunk/Cargo Lighting
REAR WIPERRear Wiper System/Washer Pump
HVAC CTRL (IGN)Climate Control System
HVAC BLOWERClimate Control System
DOOR LOCKAutomatic Door Lock System
ROOF/HEAT SEATSunroof, Heated Seats, Automatic Dimming Rearview Mirror, Compass, Rear Wiper/Washer System
POWER WINDOWSPower Window Switch
NOT INSTALLEDNot Used
NOT INSTALLEDNot Used
AIRBAG (BATT)Airbag System
FUSE PULLERFuse Puller
SPARE FUSE HOLDERSpare
SPARE FUSE HOLDERSpare
SPARE FUSE HOLDERSpare
SPARE FUSE HOLDERSpare

Engine Compartment Fuse Box

Fuse box location

It is located in the engine compartment (left-side), under the cover.

Advertisements

Fuse box diagram

Assignment of the fuses and relay in the Engine Compartment
NameUsage
1Air Conditioning Clutch
2Electronic Throttle Control
3Engine Control Module (IGN 1) (V6)
4Transmission
52004-2005: Fuel Injectors
6Emission 1
7Left Headlamp Low-Beam
8Horn
9Right Headlamp Low-Beam
10Front Fog Lamps
11Left Headlamp High-Beam
12Right Headlamp High-Beam
13Engine Control Module (BATT) (L4)
14Windshield Wiper
15Anti-lock Brake System
16Engine Control Module (IGN 1) (L4)
17Cooling Fan 1
18Cooling Fan 2
19Run Relay
20IBCM 1
21IBCM (R/C)
22Rear Electrical Center 1
23Rear Electrical Center 2
24Anti-lock Brake System
25IBCM2
26Starter
27 (DIODE)Windshield Wiper
41Electric Power Steering
42Transaxle Control Module
43Ignition Module
442006-2007: Fuel Injectors
45Rear Oxygen Sensors
46 (Resistor)Brake Lamp Diagnostic
47Daytime Running Lamps
51Engine Control Module (BATT) (V6)
Relays
28Cooling Fan 1
29Cooling Fan Mode Series/Parallel
30Cooling Fan 2
31Starter
32Run/Crank, Ignition
33Powertrain
34Air Conditioning Clutch
35High-Beam Headlamps
36Front Fog Lamps
37Horn
38Low-Beam Headlamps
39Windshield Wiper 1
40Windshield Wiper 2
48Daytime Running Lamps

Luggage Compartment Fuse Box

Fuse box location

Rear Compartment Fuse Block is located in the luggage compartment (on the left-side), behind the cover.

Advertisements

Fuse box diagram

Assignment of the fuses and relay in the Luggage Compartment
NameUsage
1Not Used
2Driver Seat Controls
3Not Used
4 (Resistor)Driver Door Key Lock Cylinder / Not Used
5Emission
6Parklamps
7Not Used
8Not Used
9Not Used
10Sunroof Controls
11Not Used
12Auxiliary Power 2
13Not Used
14Heated Seat Controls
15Not Used
16Remote Keyless Entry System, XM Satellite Radio, Rear Seat Entertainment System, Homelink
17Back-up Lamps
18Not Used
19Not Used
20Cigarette Lighter, Auxiliary Power Outlet
21Not Used
22Trunk
23Rear Window Defogger
24Heated Mirror Controls
25Fuel Pump
Relays
26Rear Window Defogger
27Parklamps
28Not Used
29Not Used
30Not Used
31Not Used
32Not Used
33Back-up Lamps
34Not Used
35Not Used
36Trunk
37Fuel Pump
38 (Diode)Trunk, Cargo Lamps

Advertisements