Advertisements
Here you will find fuse box diagrams of Ford F-53 Motorhome Chassis and F-59 Commercial Stripped Chassis 2013, 2016 and 2017, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
Fuse Layout Ford F53 / F59 Stripped Chassis 2013, 2016, 2017
Table of Contents
Fuse box location
Fuse box location
Passenger compartment
The fuse panel is located below and to the left of the steering wheel by the brake pedal.
Engine compartment
The power distribution box is located in the engine compartment.
Diode and Relay Module
The module box is located by the power distribution box in front of the radiator in the engine compartment.
Fuse Holder Module
The fuse holder module is located next to the diode/relay module.
Fuse box diagrams
Fuse box diagrams
2013 (F-53)
Passenger compartment
Advertisements
Assignment of the fuses in the Passenger compartment (2013)
| № | Amp rating | Protected circuits |
|---|---|---|
| 1 | 20A | Turn/stop lamps, Turn indicators, Body builder rear turn/stop feeds |
| 2 | — | Not used |
| 3 | — | Not used |
| 4 | 10A | Instrument panel cluster |
| 5 | 10A | Body builder accessory feed (accessory and run) |
| 6 | — | Not used |
| 7 | 15A | Blower motor relay coil |
| 8 | 10A | Brake lamps feed |
| 9 | 20A | Stop lamps: Vehicle turn/stop lamps, Body builder rear turn/stop feeds, Body builder stop lamp feed |
| 10 | 10A | Instrument cluster memory, Power brake assist lamp -Hydromax |
| 11 | 30A | Wiper/washer module, Wiper feed |
| 12 | — | Not used |
| 13 | 10A | Anti-lock brake system module -Hydromax |
| 14 | 10A | Warning chime module, Power brake assist module - Hydromax, Instrument cluster power, Instrument cluster warning lamps, Anti-lock brake system module -Hydroboost |
| 15 | 15A | Left turn signal feed |
| 16 | 20A | Body builder battery (+12V) feed |
| 17 | 5A | Body builder radio feed |
| 18 | — | Not used |
| 19 | 5A | Daytime running lamps relays |
| 20 | — | Not used |
| 21 | 15A | Right turn signal feed |
| 22 | 20A | Trailer tow turn signals |
| 23 | 10A | Cluster run/accessory |
| 24 | — | Not used |
| 25 | 10A | Body builder right-hand low beam headlamp feed |
| 26 | 10A | Brake shift interlock actuator |
| 27 | — | Not used |
| 28 | — | Not used |
| 29 | — | Not used |
| 30 | — | Not used |
| 31 | 10A | Body builder left-hand low beam headlamp feed |
| 32 | — | Not used |
| 33 | 10A | Reverse lamps |
| 34 | 10A | Trailer tow reverse lamps, Body builder reverse gear |
| 35 | 20A | Body builder high beam feed, High beam indicator, Daytime running lamps |
| 36 | — | Not used |
| 37 | — | Not used |
| 38 | 10A | Body builder run feed |
| 39 | — | Not used |
| 40 | — | Not used |
| 41 | 10A | Instrument illumination |
| 42 | — | Not used |
| 43 | — | Not used |
| 44 | — | Not used |
| Relay 1 | — | Trailer tow right turn signal |
| Relay 2 | — | Trailer tow left turn signal |
| Relay 3 | — | Right turn signal |
| Relay 4 | — | Left turn signal |
| Relay 5 | — | Not used |
| Relay 6 | — | Daytime running lamps, Parking brake |
| Relay 7 | — | Daytime running lamps on/off |
| Diode 1 | — | Brake transmission shift interlock |
| Diode 2 | — | Brake transmission shift interlock |
| F1 | — | Not used |
| F2 | — | Not used |
| F3 | — | Not used |
| F4 | 10A | Brake transmission shift interlock |
| F5 | — | Not used |
| F6 | — | Not used |
| F7 | — | Not used |
| F8 | — | Not used |
| F9 | — | Not used |
| F10 | — | Not used |
| F11 | — | Not used |
| F12 | — | Not used |
Engine compartment
Advertisements
Assignment of the fuses in the Power distribution box (2013)
| № | Amp rating | Protected Components |
|---|---|---|
| 1 | 5A* | Power brake assist module -Hydromax |
| 2 | 10 A* | A/C compressor clutch |
| 3 | 20A* | A/C clutch relay coil, Mass air flow sensor with intake air temperature, Vapor management valve, Engine heated exhaust gas oxygen sensor #11 and #21, Catalyst monitor sensor |
| 4 | 5A* | Powertrain control module memory |
| 5 | 20A* | Powertrain control module power |
| 6 | 20A* | Park lamp feeds, Instrument panel fuse #41, Warning chime module, Trailer tow running lamp relay coil, Instrument panel dimmer module |
| 7 | 20A* | Ignition coils, Radio capacitors |
| 8 | 30A* | Hydromax - Anti-lock brake system module |
| 9 | 10 A* | Starter main relay coil, Starter ground relay coil |
| 10 | 20A* | Daytime running lamps |
| 11 | 20A* | Fuel pump relay coil, Powertrain control module power |
| 12 | 25A* | Trailer tow back-up lamps feed, Instrument panel - backup lamp feed |
| 13 | 30A** | Trailer tow electric brake controller feed |
| 14 | 60A** | Instrument panel battery feed (fuse #9, 15, 21) |
| 15 | 20A** | Trailer tow park lamps |
| 16 | 60A** | Anti-lock brake system module -Hydromax |
| 16 | 40A** | Anti-lock brake system module -Hydroboost |
| 17 | 20A** | Horn feed |
| 18 | 20A** | Transmission control indicator light, Tow/haul switch, Backup lamp feed |
| 19 | — | Not used |
| 20 | 30A** | Powertrain control module relay coil, Powertrain control module relay (Power distribution box fuses # 3, 5, 7, 18) |
| 21 | 20A** | Fuel pump motor, Fuel injectors |
| 22 | 20A** | Diagnostic tool connector, Cigar lighter feed |
| 23 | 40A** | Blower motor feed |
| 24 | 50A** | Instrument panel battery feed (fuses #4, 10, 16, 22) |
| 25 | 40A** | Ignition switch feed (Instrument panel fuses #1, 5, 7, 11, 13, 14, 17, 19, 23; Power distribution box fuses #9, 11) |
| 26 | 40A** | Ignition switch feed (Instrument panel fuses #5, 11, 17, 23, 26, 38) |
| 27 | 30A** | Multi-function switch (headlamps) |
| 28 | 30A** | Starter solenoid |
| 29 | 60A** | Power brake assist motor -Hydromax |
| 29 | 40A** | Anti-lock brake system module -Hydroboost |
| R1 | — | A/C clutch relay |
| R2 | — | Fuel pump relay |
| R3 | — | Horn relay |
| R4 | — | Starter relay |
| R5 | — | Blower motor relay |
| R6 | — | Powertrain control module relay |
| Diode 1 | — | Fuel pump diode |
| Diode 2 | — | A/C clutch diode |
| * Mini Fuses ** Maxi Fuses |
Advertisements
Diode and Relay Module (2013)
| Relay Location | Description |
|---|---|
| 1 | One touch integrated start (ATO diode) |
| 2 | Not used |
| 3 | Not used |
| 4 | Daytime running lamps power relay |
| 5 | Hydromax - brake on/off signal isolating relay |
| 6 | Reverse lamps relay |
| 7 | Starter ground relay |
| 8 | Trailer tow parking lamps relay |
| Fuse Holder Module | |
| 1 | 10A - Hydromax - brake on/off signal |
2016
Advertisements
F53 Power Distribution Box (2016)
| № | Amp rating | Protected components |
|---|---|---|
| 1 | 5A* | Power brake assist module - Hydromax. |
| 2 | 10 A* | Air conditioning compressor clutch. |
| 3 | 20A* | Catalyst monitor sensor. Engine heated exhaust gas oxygen sensor #11 and #21. Vapor management valve. |
| 4 | 5A* | Powertrain control module memory. Powertrain control module relay coil. |
| 5 | 20A* | Powertrain control module power. |
| 6 | 20A* | Instrument panel dimmer module. Park lamp feeds. Trailer tow running lamp relay coil. |
| 7 | 20A* | Ignition coils. Radio capacitors. |
| 8 | 30 A* | Hydromax - Anti-lock brake system module. |
| 9 | 10 A* | Powertrain control module. |
| 10 | 20A* | Daytime running lamps. |
| 11 | 20A* | Fuel pump relay coil. Powertrain control module power. Fuel pump diode. |
| 12 | 25 A* | Instrument panel - backup lamp feed. Trailer tow backup lamps feed. |
| 13 | 30A** | Trailer tow electric brake controller feed. |
| 14 | 60 A** | Instrument panel battery feed (fuse #9,15, 21). Lighting primary fuse. |
| 15 | 20A** | Trailer tow park lamps. |
| 16 | 60 A** | Anti-lock brake system module -Hydromax. |
| 16 | 40A** | Anti-lock brake system module - Hydroboost. |
| 17 | 20A** | Horn feed. |
| 18 | 20A** | Backup lamp relay coil. A/C clutch coil. A/C demand switch. |
| 19 | — | Not used. |
| 20 | 30 A** | Powertrain control module relay coil. Powertrain control module relay (Power distribution box fuses # 3, 5,7,18). |
| 21 | 20A** | Fuel injectors. Fuel pump motor. Mass air flow sensor. |
| 22 | 20A** | Cigar lighter feed. Diagnostic tool connector. |
| 23 | 40A** | Blower motor feed. |
| 24 | 50A** | Instrument panel battery feed (fuses #4, 10,16,22). |
| 25 | 40A** | Ignition switch feed (Instrument panel fuses #1, 5,7,11,13,14,17,19,23,36; Power distribution box fuses #9,11). |
| 26 | 40A** | Ignition switch feed (Instrument panel fuses #5,11,17,23,26,38). |
| 27 | 30 A** | Multi-function switch (headlamps). |
| 28 | 30 A** | Starter relay feed. Starter motor. |
| 29 | 60A** | Power brake assist motor - Hydromax. |
| 29 | 40A** | Anti-lock brake system module - Hydroboost. |
| R1 | — | Air conditioning clutch relay. |
| R2 | — | Fuel pump relay. |
| R3 | — | Horn relay. |
| R4 | — | Starter relay. |
| R5 | — | Blower motor relay. |
| R6 | — | Powertrain control module relay. |
| Diode 1 | — | Fuel pump diode. |
| Diode 2 | — | Air conditioning clutch diode. |
| * Mini fuses. ** Maxi fuses. |
Advertisements
F59 Power Distribution Box (2016)
| № | Amp rating | Protected components |
|---|---|---|
| F1 | 10 A* | Air conditioning compressor clutch. |
| F2 | 30 A* | Anti-lock brake system - Hydromax. |
| F3 | 5A* | Powertrain control module keep alive memory. Powertrain control module relay coil. |
| F4 | — | Not used. |
| F5 | 20A* | Running lamps. Trailer tow lamp relay coil. |
| F6 | — | Not used. |
| F7 | 25 A* | Reverse lamps. Instrument panel fuses #33,34. |
| F8 | — | Not used. |
| F9 | 20A* | Daytime running lamps. |
| F10 | — | Not used. |
| F11 | — | Not used. |
| F12 | — | Not used. |
| F13 | — | Not used. |
| F14 | — | Not used. |
| F15 | 5A* | Hydromax pump motor. |
| F16 | 20A* | Vehicle power 1. Powertrain control module power. |
| F17 | 20A* | Vehicle power 2. Catalyst monitor sensor. Engine heated exhaust gas oxygen sensor #11 and #21. Vapor management valve. |
| F18 | 20A* | Vehicle power 4. Ignition coils. |
| F19 | 10 A* | Powertrain control module. |
| F20 | 10 A* | Hydromax module. Brake on/off relay feed. |
| F21 | 20A* | Powertrain control module. Fuel pump diode. |
| F22 | — | Not used. |
| F23 | — | Not used. |
| F24 | — | Not used. |
| J1 | 40A** | Blower motor relay feed. |
| J2 | 30A** | Headlamps. Daytime running lamps on/off relay coil. Headlamp daytime running lamp relay feed. Instrument panel fuses #25,31. |
| J3 | 30A** | Vehicle power. Powertrain control module relay feed. Power distribution box fuse FI 6, F17, F18, J22. |
| J4 | 20A** | Cigar lighter feed. Diagnostic tool connector. |
| J5 | — | Not used. |
| J6 | 30A** | Starter relay feed. Starter motor. |
| J7 | 40A** / 60 A** | Anti-lock brake system. Hydromax pump |
| J8 | 20A** | Trailer tow park lamps. |
| J9 | 50A** | Instrument panel fuse #4,10,16,22. |
| J10 | 60 A** | 4-channel anti-lock brake system module. |
| J10 | 40A** | 3-channel anti-lock brake system module. |
| J11 | 20A** | Fuel pump relay feed. Fuel injectors. Mass air flow sensor. Fuel pump motor. |
| J12 | 30A** | Trailer tow electronic brake. |
| J13 | 40A** | Ignition switch feed (instrument panel fuses #1,5,7,11,13,17,19, 23). |
| J14 | — | Not used. |
| J15 | 60 A** | Instrument panel fuses #9,15,21. |
| J16 | 20A** | Horn. |
| J17 | 40A** | Ignition switch feed (instrument panel fuses #1,5,7,11,13,17,19, 23. |
| J18 | — | Not used. |
| J19 | — | Not used. |
| J20 | — | Not used. |
| J21 | — | Not used. |
| J22 | 20A** | Reverse lamp relay coil. A/C clutch relay coil. A/C demand switch. |
| R1 | — | Horn relay. |
| R2 | — | Fuel pump relay. |
| R3 | — | Starter relay. |
| R4 | — | Backup lamps relay. |
| R5 | — | Brake on/off relay. |
| R6 | — | Trailer tow parking lamps relay. |
| R7 | — | Not used. |
| R8 | — | Air conditioning clutch relay. |
| R9 | — | Not used. |
| R10 | — | Starter relay. |
| R11 | — | Blower motor relay. |
| R12 | — | Daytime running lamp/headlamp relay. |
| R13 | — | Powertrain control module relay. |
| D1 | — | Fuel pump diode. |
| D2 | — | Air conditioning clutch diode. |
| D3 | — | Not used. |
| C1 | — | Not used. |
| * Mini fuses. ** J-case fuse. |
Advertisements
UPS Power Distribution Box 1 (2016)
| № | Amp rating | Protected components |
|---|---|---|
| R1 | Relay | Powertrain control module. |
| R2 | Relay | Daytime running lamps. |
| R3 | Relay | Starter motor. |
| R4 | Relay | Blower motor. |
| R5 | Relay | Horn. |
| R6 | Relay | Fuel pump. |
| R7 | Relay | Starter ground. |
| R8 | Relay | Trailer tow parking lamps. |
| R9 | Relay | Backup lamps. |
| R10 | Relay | Hydromax brake on/off relay. |
| R11 | Relay | Not used. |
| R12 | Relay | Air conditioning clutch. |
| M1-1 | 10A | Hydromax brake on/off relay. |
| M1-2 | 20A | Turn/hazard brake lighting. |
| M1-3 | — | Not used. |
| M1-4 | — | Not used. |
Advertisements
UPS Power Distribution Box 2 (2016)
| № | Amp rating | Protected components |
|---|---|---|
| M1 | 25 A* | Backup lamps. |
| M2 | 20A* | Daytime running lamps. |
| M3 | 30 A* | 4-channel anti-lock brake system module (Hydromax). |
| M4 | 20A* | Powertrain control module run/start. Fuel pump relay coil. |
| M5 | 10 A* | Starter relay coil. |
| M6 | 20A* | Vehicle power 4. Ignition coils. |
| M7 | 5A* | Hydromax motor monitor. |
| M8 | 20A* | Vehicle power 2. |
| M9 | 20A* | Vehicle power 1. Mass air flow sensor. |
| M10 | 10 A* | Air conditioning. |
| M11 | 5A* | Powertrain control module relay keep alive power. Canister vent valve. |
| M12 | 20A* | Parking lamps feed. Trailer tow running lamp relay coil. |
| D1 | Diode | One-touch start. |
| D2 | Diode | Fuel pump. |
| D3 | Diode | Air conditioning. |
| R2-1 | — | Not used. |
| J1 | 30A** | Powertrain control module vehicle power. |
| J2 | 20A** | Fuel pump. |
| J3 | 20A** | Cigar lighter power point. Diagnostic connector. |
| J4 | 40A** | Blower motor. |
| J5 | 30A** | Headlamps. Daytime running lamps on/off relay coil. Headlamp daytime running lamp relay feed. |
| J6 | 40A** | Ignition switch feeds (instrument panel fuses #F26). |
| J7 | 40A** | Ignition switch feeds (instrument panel #F21, F26). |
| J8 | 50A** | Instrument panel fuse box Fll, F13, F15. |
| J9 | 30A** | Starter relay feed. |
| J10 | 60 A** | 4-channel anti-lock brake system module (Hydromax). |
| J11 | 30A** | Trailer tow electronic brake. |
| J12 | 60 A** | Lighting (instrument panel fuses #F3, F5; power distribution box Ml-2). |
| J13 | 20A** | Vehicle power 3. |
| J14 | 20A** | Horn. |
| J15 | 60 A** | 4-channel anti-lock brake system module. |
| J16 | 20A** | Trailer tow parking lamps. |
| * Mini fuse. ** J-case fuse. |
Advertisements
Diode and Relay Module (2016)
| № | Amp rating | Protected components |
|---|---|---|
| 1 | Not used. | |
| 2 | Not used. | |
| 3 | Not used. | |
| 4 | Daytime running lamps power relay. | |
| 5 | Hydromax - brake on/off signal isolating relay. | |
| 6 | Reverse lamps relay. | |
| 7 | Starter ground relay. | |
| 8 | Trailer tow parking lamps relay. | |
| Fuse Holder Module | ||
| 1 | 10A | Hydromax - brake on/off signal. |
Advertisements
F53/F59 Passenger Compartment Fuse Panel (2016)
| № | Amp rating | Protected components |
|---|---|---|
| 1 | 20A | Multi function switch. |
| 2 | — | Not used. |
| 3 | — | Not used. |
| 4 | 10A | Instrument cluster. |
| 5 | 10A | Body builder accessory feed (accessory and run). |
| 6 | — | Not used. |
| 7 | 15A | Blower motor relay coil. |
| 8 | 10A | Brake lamps feed. |
| 9 | 20A | Stop lamps: Vehicle direction indicators and stop lamps, Body builder rear direction indicators and stop feeds, Body builder stop lamp feed. |
| 10 | 10A | Instrument cluster memory. |
| 11 | 30A | Wiper/washer module. Wiper feed. |
| 12 | — | Not used. |
| 13 | 10A | Anti-lock brake system module -Hydromax. |
| 14 | 10A | Anti-lock brake system module - Hydroboost. Instrument cluster run/start. |
| 15 | 15A | Left-hand direction indicator feed. |
| 16 | 20A | Body builder battery (+12V) feed. |
| 17 | 5A | Body builder radio feed. |
| 18 | — | Not used. |
| 19 | 5A | Daytime running lamps relays. |
| 20 | — | Not used. |
| 21 | 15A | Right-hand direction indicator feed. |
| 22 | 20A | Trailer tow direction indicators. |
| 23 | 10A | Cluster run/accessory. |
| 24 | — | Not used. |
| 25 | 10A | Body builder right-hand low beam headlamp feed. |
| 26 | 10A | Brake shift interlock diode and solenoid. |
| 27 | — | Not used. |
| 28 | — | Not used. |
| 29 | — | Not used. |
| 30 | — | Not used. |
| 31 | 10A | Body builder left-hand low beam headlamp feed. |
| 32 | — | Not used. |
| 33 | 10A | Body builder reverse lamp power. |
| 34 | 10A | Body builder reverse gear. Trailer tow reverse lamps. |
| 35 | 20A | Body builder high beam feed. High beam indicator. |
| 36 | 10A | Transmission control switch. |
| 37 | — | Not used. |
| 38 | 10A | Body builder run feed. |
| 39 | — | Not used. |
| 40 | — | Not used. |
| 41 | 10A | Instrument cluster lighting. |
| 42 | — | Not used. |
| 43 | — | Not used. |
| 44 | — | Not used. |
| Relay 1 | — | Trailer tow right-hand direction indicator. |
| Relay 2 | — | Trailer tow left-hand direction indicator. |
| Relay 3 | — | Right-hand direction indicator. |
| Relay 4 | — | Left-hand direction indicator. |
| Relay 5 | — | Not used. |
| Relay 6 | — | Daytime running lamps. Parking brake. |
| Relay 7 | — | Daytime running lamps on/off. |
| Diode 1 | — | Brake transmission shift interlock. |
| Diode 2 | — | Brake transmission shift interlock. |
| F1 | — | Not used. |
| F2 | — | Not used. |
| F3 | — | Not used. |
| F4 | 10A | Brake transmission shift interlock. |
| F5 | — | Not used. |
| F6 | — | Not used. |
| F7 | — | Not used. |
| F8 | — | Not used. |
| F9 | — | Not used. |
| F10 | — | Not used. |
| F11 | — | Not used. |
| F12 | — | Not used. |
UPS Passenger Compartment Fuse Panel (2016)
Advertisements
UPS Passenger Compartment Fuse Panel (2016)
| № | Amp rating | Protected components |
|---|---|---|
| F1 | — | Not used. |
| F2 | 20A | Flasher run. |
| F3 | 15A | Left turn. |
| F4 | 15A | Blower relay coil. |
| F5 | 15A | Right turn. |
| F6 | 10A | ABS run. |
| F7 | 10A | Right body builder headlamp. |
| F8 | 5A | Daytime running lamps. |
| F9 | 10A | Left body builder headlamp. |
| F10 | — | Not used. |
| F11 | 10A | Cluster battery (+12V) #1. |
| F12 | 5A | UPS brake transmission shift interlock. |
| F13 | 10A | Cluster battery (+12V) #2. |
| F14 | 10A | Switch illumination. |
| F15 | 20A | Body builder battery (+12V) feed. |
| F16 | — | Not used. |
| F17 | 20A | Trailer tow run relay feed. |
| F18 | 10A | Body builder run. |
| F19 | 10A | Brake lamp feed. |
| F20 | 10A | Body builder run. |
| F21 | 10A | Run/start. |
| F22 | 30A | Wiper module battery (+12V). |
| F23 | 10A | Reverse lamps. |
| F24 | 5A | Body builder radio. |
| F25 | 10A | Trailer tow reverse lamps. |
| F26 | 10A | Cluster run/start. |
| F27 | 20A | Body builder high beam feed. |
| R1 | — | Daytime running lamps. Parking brake. |
| R2 | — | Daytime running lamps on/off. |
| R3 | — | Right-hand direction indicator. |
| R4 | — | Trailer tow right-hand direction indicator. |
| R5 | — | Left-hand direction indicator. |
| R6 | — | Trailer tow left-hand direction indicator. |
| R7 | — | Not used. |
| R8 | — | Not used. |
| R9 | — | Not used. |
| D1 | — | Not used. |
| D2 | — | Not used. |
| D3 | — | Not used. |
2017
Advertisements
F53 Power Distribution Box (2017)
| № | Amp rating | Protected components |
|---|---|---|
| 1 | 5A* | Power brake assist module - Hydromax. |
| 2 | 10 A* | Air conditioning compressor clutch. |
| 3 | 20A* | Catalyst monitor sensor. Engine heated exhaust gas oxygen sensor #11 and #21. Vapor management valve. |
| 4 | 5A* | Powertrain control module relay coil. Powertrain control module keep alive memory. |
| 5 | 20A* | Powertrain control module power. |
| 6 | 20A* | Instrument panel dimmer module. Park lamp feeds. Trailer tow running lamp relay coil. |
| 7 | 20A* | Ignition coils. Radio capacitors. |
| 8 | 30 A* | Hydromax - Anti-lock brake system module. |
| 9 | 10 A* | Powertrain control module. |
| 10 | 20A* | Daytime running lamps. |
| 11 | 20A* | Fuel pump relay coil. Powertrain control module. Fuel pump diode. |
| 12 | 25 A* | Instrument panel - backup lamp feed. Trailer tow backup lamps feed. |
| 13 | 30A** | Trailer tow electric brake controller feed. |
| 14 | 60 A** | Instrument panel battery feed (fuse #15, 21). Lighting primary fuse. Power distribution box fuse #19. |
| 15 | 20A** | Trailer tow park lamps. |
| 16 | 60 A** | Anti-lock brake system module -Hydromax. |
| 16 | 40A** | Anti-lock brake system module - Hydroboost. |
| 17 | 20A** | Horn feed. |
| 18 | 20A** | Backup lamp relay coil. A/C clutch coil. A/C demand switch. |
| 19 | 20A** | Brake on/off switch. Multifunction switch. |
| 20 | 30 A** | Powertrain control module relay (Power distribution box fuses # 3, 5,7,18). |
| 21 | 20A** | Fuel injectors. Fuel pump motor. Mass air flow sensor. Powertrain control module. |
| 22 | 20A** | Cigar lighter feed. Diagnostic tool connector. |
| 23 | 40A** | Blower motor feed. |
| 24 | 50A** | Instrument panel battery feed (fuses #4, 10,16,22). |
| 25 | 40A** | Ignition switch feed (Instrument panel fuses #1, 5,7,11,13,14,17,19,23,36; Power distribution box fuses #9,11). Fuse holder #2. |
| 26 | 40A** | Ignition switch feed (Instrument panel fuses #5,11,17,23,38). |
| 27 | 30 A** | Headlamps. Daytime running lamps on/off relay coil. Headlamp daytime running lamp relay feed. High beam headlamps flash to pass. (Instrument panel fuses #25,31). |
| 28 | 30 A** | Starter relay feed. Starter motor solenoid. |
| 29 | 60A** | Power brake assist motor - Hydromax. Fuse holder #1. |
| 29 | 40A** | Anti-lock brake system module - Hydroboost. |
| R1 | — | Air conditioning clutch relay. |
| R2 | — | Fuel pump relay. |
| R3 | — | Horn relay. |
| R4 | — | Starter relay. |
| R5 | — | Blower motor relay. |
| R6 | — | Powertrain control module relay. |
| Diode 1 | — | Fuel pump diode. |
| Diode 2 | — | Air conditioning clutch diode. |
| * Mini fuses. ** Maxi fuses. |
Advertisements
F59 Power Distribution Box (2017)
| № | Amp rating | Protected components |
|---|---|---|
| F1 | 10 A* | Air conditioning compressor clutch. |
| F2 | 30 A* | Anti-lock brake system - Hydromax. |
| F3 | 5A* | Powertrain control module keep alive memory. Powertrain control module relay coil. |
| F4 | — | Not used. |
| F5 | 20A* | Trailer tow running lamp relay coil. Park lamp feeds. Instrument panel dimmer module. |
| F6 | — | Not used. |
| F7 | 25 A* | Trailer tow backup lamp feed. Backup lamp feed. |
| F8 | — | Not used. |
| F9 | 20A* | Daytime running lamps. |
| F10 | — | Not used. |
| F11 | — | Not used. |
| F12 | — | Not used. |
| F13 | — | Not used. |
| F14 | — | Not used. |
| F15 | 5A* | Power brake assist module (Hydromax). |
| F16 | 20A* | Powertrain control module power. |
| F17 | 20A* | Catalyst monitor sensor. Engine heated exhaust gas oxygen sensor #11 and #21. Vapor management valve. |
| F18 | 20A* | Radio capacitors. Ignition coils. |
| F19 | 10 A* | Powertrain control module. |
| F20 | 10 A* | Hydromax module brake on/off relay feed. |
| F21 | 20A* | Powertrain control module. Fuel pump diode. Fuel pump relay coil. |
| F22 | 10 A* | Brake transmission shift interlock. |
| F23 | — | Not used. |
| F24 | — | Not used. |
| J1 | 40A** | Blower motor relay feed. |
| J2 | 30A** | Headlamps. High beam headlamps flash to pass. Daytime running lamps on/off relay coil. Headlamp daytime running lamp relay feed. Instrument panel fuses #25,31. |
| J3 | 30A** | Vehicle power. Powertrain control module relay feed. Power distribution box fuse F16, F17, F18, J22. |
| J4 | 20A** | Cigar lighter feed. Diagnostic tool connector. |
| J5 | — | Not used. |
| J6 | 30A** | Starter relay feed. Starter motor solenoid. |
| J7 | 40A** | Anti-lock brake system module (Hydroboost). |
| J7 | 60 A** | Power brake assist motor (Hydromax). Power distribution box fuse #F20. |
| J8 | 20A** | Trailer tow park lamps. |
| J9 | 50A** | Instrument panel fuse #4,10,16,22. |
| J10 | 60 A** | 4-channel anti-lock brake system module. |
| J10 | 40A** | 3-channel anti-lock brake system module. |
| J11 | 20A** | Fuel pump relay feed. Fuel injectors. Mass air flow sensor. Fuel pump motor. Powertrain control module. |
| J12 | 30 A** | Trailer tow electronic brake. |
| J13 | 40A** | Ignition switch feed (instrument panel fuses #1, 5,7,11,13,14,17,19,23,36). (Power distribution box fuse #F19, F22, F21). |
| J14 | — | Not used. |
| J15 | 60A** | Instrument panel battery feed (fuse #15, 21). Lighting primary fuse. |
| J16 | 20A** | Horn. |
| J17 | 40A** | Ignition switch feed (instrument panel fuses #5,11,17,23,38). |
| J18 | 20** | Brake on/off switch. Multifunction switch. |
| J19 | — | Not used. |
| J20 | — | Not used. |
| J21 | — | Not used. |
| J22 | 20A** | Reverse lamp relay coil. A/C clutch relay coil. A/C demand switch. |
| R1 | — | Horn relay. |
| R2 | — | Fuel pump relay. |
| R3 | — | Starter relay. |
| R4 | — | Backup lamps relay. |
| R5 | — | Brake on/off signal isolating relay (Hydromax). |
| R6 | — | Trailer tow parking lamps relay. |
| R7 | — | Not used. |
| R8 | — | Air conditioning clutch relay. |
| R9 | — | Not used. |
| R10 | — | Starter relay. |
| R11 | — | Blower motor relay. |
| R12 | — | Daytime running lamp/headlamp relay. |
| R13 | — | Powertrain control module relay. |
| D1 | — | Fuel pump diode. |
| D2 | — | Air conditioning clutch diode. |
| D3 | — | Not used. |
| C1 | — | Not used. |
| * Mini fuses. ** J-case fuse. |
Advertisements
UPS Power Distribution Box 1 (2017)
| № | Amp rating | Protected components |
|---|---|---|
| R1 | Relay | Powertrain control module. |
| R2 | Relay | Daytime running lamps. |
| R3 | Relay | Starter motor. |
| R4 | Relay | Blower motor. |
| R5 | Relay | Horn. |
| R6 | Relay | Fuel pump. |
| R7 | Relay | Starter ground. |
| R8 | Relay | Trailer tow parking lamps. |
| R9 | Relay | Backup lamps. |
| R10 | Relay | Hydromax brake on/off relay. |
| R11 | Relay | Not used. |
| R12 | Relay | Not used. |
| M1-1 | 10A | Hydromax brake on/off relay. |
| M1-2 | 20A | BTSI (Column shift). |
| M1-3 | 5A | Power brake assist module (Hydromax). |
| M1-4 | 10A | Powertrain control module. |
Advertisements
UPS Power Distribution Box 2 (2017)
| № | Amp rating | Protected components |
|---|---|---|
| M1 | 25 A* | Backup lamp feed. Trailer tow backup lamp feed. |
| M2 | 20A* | Daytime running lamps. |
| M3 | 30 A* | 4-channel anti-lock brake system module (Hydromax). |
| M4 | 20A* | Powertrain control module run/start. Fuel pump relay coil. Fuel pump diode. |
| M5 | 10 A* | Brake lamps. |
| M6 | 20A* | Radio capacitors. Ignition coils. |
| M7 | 5A* | Backup lamp relay coil. Air conditioning clutch coil. Air conditioning demand switch. |
| M8 | 20A* | Catalyst monitor sensor. Engine heated exhaust gas oxygen sensor #11 and #21. Vapor management valve. |
| M9 | 20A* | Powertrain control module power. |
| M10 | — | Not used. |
| M11 | 5A* | Powertrain control module relay keep alive power. Powertrain control module relay coil. |
| M12 | 20A* | Parking lamps feed. |
| D1 | Diode | Not used. |
| D2 | Diode | Fuel pump. |
| D3 | Diode | Air conditioning clutch. |
| R2-1 | — | Not used. |
| J1 | 30A** | Powertrain control module relay feed (power distribution box fuse M6, M7, M8, M9). |
| J2 | 20A** | Fuel injectors. Fuel pump motor. Mass airflow sensor. Powertrain control module. |
| J3 | 20A** | Cigar lighter power point. Diagnostic connector. |
| J4 | 40A** | Blower motor. |
| J5 | 30A** | Headlamps. Daytime running lamps on/off relay coil. Headlamp daytime running lamp relay feed. High beam headlamps flash to pass. (Instrument panel fuses #25,31). |
| J6 | 40A** | Ignition switch feeds (instrument panel fuses #F26). |
| J7 | 40A** | Instrument panel fuses #F24, F22, F20, F26, F21, F8, F6, F4, F2. Power distribution box fuses M4, Ml-4. |
| J8 | 50A** | Instrument panel fuses Fll, F13, F15, F17. |
| J9 | 30 A** | Starter relay feed. Starter motor solenoid. |
| J10 | 60A** | Power distribution box fuse Ml-1. Power brake assist motor (Hydromax). |
| J11 | 30 A** | Trailer tow electronic brake. |
| J12 | 60A** | Lighting primary. Power distribution box fuse Ml-2. Instrument panel fuses #F19, F5, F3. |
| J13 | — | Not used. |
| J14 | 20A** | Horn. |
| J15 | 60A** | 4-channel anti-lock brake system module. |
| J16 | 20A** | Trailer tow parking lamps. |
Diode and Relay Module (2017)
| № | Amp rating | Protected components |
|---|---|---|
| 1 | Not used. | |
| 2 | Not used. | |
| 3 | Not used. | |
| 4 | Daytime running lamps power relay. | |
| 5 | Hydromax - brake on/off signal isolating relay. | |
| 6 | Reverse lamps relay. | |
| 7 | Starter ground relay. | |
| 8 | Trailer tow parking lamps relay. | |
| Fuse Holder Module | ||
| 1 | 10A | Break on/off relay feed (Hydromax module). |
| 2 | 10A | Brake transmission shift interlock. |
F53 Passenger Compartment Fuse Panel (2017)
Advertisements
F53 Passenger Compartment Fuse Panel (2017)
| № | Amp rating | Protected components |
|---|---|---|
| 1 | 20A* | Multi function switch. |
| 2 | — | Not used. |
| 3 | — | Not used. |
| 4 | 10 A* | Instrument cluster. |
| 5 | 10 A* | Body builder accessory feed (accessory and run). |
| 6 | — | Not used. |
| 7 | 15 A* | Blower motor relay coil. |
| 8 | 10 A* | Brake lamps feed. Trailer brake control module |
| 9 | — | Not used. |
| 10 | 10 A* | Instrument cluster memory. |
| 11 | 30 A* | Wiper/washer module. Wiper feed. |
| 12 | — | Not used. |
| 13 | 10 A* | Anti-lock brake system module -Hydromax. |
| 14 | 10 A* | Anti-lock brake system module - Hydroboost. Instrument cluster run/start. |
| 15 | 15 A* | Left-hand direction indicator feed. |
| 16 | 20A* | Body builder battery (+12V) feed. |
| 17 | 5A* | Body builder radio feed. |
| 18 | — | Not used. |
| 19 | 5A* | Daytime running lamps relays. |
| 20 | — | Not used. |
| 21 | 15 A* | Right-hand direction indicator feed. |
| 22 | 20A* | Trailer tow direction indicators. |
| 23 | 10 A* | Cluster run/accessory. |
| 24 | — | Not used. |
| 25 | 10 A* | Body builder right-hand low beam headlamp feed. |
| 26 | — | Not used. |
| 27 | — | Not used. |
| 28 | — | Not used. |
| 29 | — | Not used. |
| 30 | — | Not used. |
| 31 | 10 A* | Body builder left-hand low beam headlamp feed. |
| 32 | — | Not used. |
| 33 | 10 A* | Body builder reverse lamp power. |
| 34 | 10 A* | Body builder reverse gear. Trailer tow reverse lamps. |
| 35 | 20A* | Body builder high beam feed. High beam indicator. |
| 36 | 10 A* | Transmission control switch. |
| 37 | — | Not used. |
| 38 | 10 A* | Body builder off/run. |
| 39 | — | Not used. |
| 40 | — | Not used. |
| 41 | 10 A* | Instrument cluster lighting/switch illumination. |
| 42 | — | Not used. |
| 43 | — | Not used. |
| 44 | — | Not used. |
| Relay 1 | — | Trailer tow right-hand direction indicator. |
| Relay 2 | — | Trailer tow left-hand direction indicator. |
| Relay 3 | — | Right-hand direction indicator. |
| Relay 4 | — | Left-hand direction indicator. |
| Relay 5 | — | Not used. |
| Relay 6 | — | Daytime running lamps. Parking brake. |
| Relay 7 | — | Daytime running lamps on/off. |
| Diode 1 | — | Not used. |
| Diode 2 | — | Not used. |
| F1 | — | Not used. |
| F2 | — | Not used. |
| F3 | — | Not used. |
| F4 | — | Not used. |
| F5 | — | Not used. |
| F6 | — | Not used. |
| F7 | — | Not used. |
| F8 | — | Not used. |
| F9 | — | Not used. |
| F10 | — | Not used. |
| F11 | — | Not used. |
| F12 | — | Not used. |
| * Mini fuse. |
F59 UPS Passenger Compartment Fuse Panel (2017)
Advertisements
F59 UPS Passenger Compartment Fuse Panel (2017)
| № | Amp rating | Protected components |
|---|---|---|
| F1 | — | Not used. |
| F2 | 20A* | Right/left rear direction indicator. Right/left direction indicator relay coil. Instrument cluster right/direction indicator indicator. |
| F3 | 15 A* | Left turn signal. Hazard lamps. |
| F4 | 15 A* | Blower motor relay coil. |
| F5 | 15 A* | Right front/rear direction indicator. Right front/rear hazard lamp. |
| F6 | 10 A* | Anti-lock brake system module (Hydromax). |
| F7 | 10 A* | Right low beam headlamp. |
| F8 | 5A* | Daytime running lamps relays. |
| F9 | 10 A* | Left low beam headlamp. |
| F10 | 10 A* | Transmission control switch. |
| F11 | 10 A* | Cluster battery (+12V) #1. |
| F12 | — | Not used. |
| F13 | 10 A* | Cluster battery (+12V) #2. |
| F14 | 10 A* | Switch illumination. Instrument cluster lighting. |
| F15 | 20A* | Body builder battery (+12V) feed. |
| F16 | — | Not used. |
| F17 | 20A* | Trailer tow direction indicators. Trailer tow stop lamps. Trailer tow hazard lamps. |
| F18 | 10 A* | Body builder off/run. |
| F19 | 10 A* | Trailer brake control module BOO signal. Body builder brake lamps. Left/right brake lamps. |
| F20 | 10 A* | Body builder run/accessory feed. |
| F21 | 10 A* | Anti-lock brake system module. Instrument cluster. |
| F22 | 30 A* | Wiper/washer module. Wiper feed. |
| F23 | 10 A* | Reverse lamps. |
| F24 | 5A* | Body builder radio feed. |
| F25 | 10 A* | Trailer tow reverse lamps. |
| F26 | 10 A* | Cluster run/accessory. |
| F27 | 20A* | High beam indicator. |
| R1 | Micro relay | Daytime running lamps. Parking brake. |
| R2 | Micro relay | Daytime running lamps on/off. |
| R3 | Micro relay | Right-hand direction indicator. |
| R4 | Micro relay | Trailer tow right-hand direction indicator. |
| R5 | Micro relay | Left-hand direction indicator. |
| R6 | Micro relay | Trailer tow left-hand direction indicator. |
| R7 | — | Not used. |
| R8 | — | Not used. |
| R9 | — | Not used. |
| D1 | — | Not used. |
| D2 | — | Not used. |
| D3 | — | Not used. |
Advertisements