Volkswagen Touareg (2006-2010) fuses and relays

Fuse box diagram (location and assignment of electrical fuses and relays) for Volkswagen (VW) Touareg (2006, 2007, 2008, 2009, 2010).

Fuse box diagram: Volkswagen Touareg (2006-2010)

Fuse box location

Fuse holder on the left side edge of the instrument panel

The location of the fuses in the passenger compartment (left): Volkswagen Touareg (2006-2010)

Fuse holder on the right side edge of the instrument panel

The location of the fuses in the passenger compartment (right): Volkswagen Touareg (2006-2010)

Pre-fuse box, under driver seat

Located near the battery under the driver seatPre-fuse box, under driver seat: Volkswagen Touareg (2006-2010)

Relay panel E-Box 1

It is located on left under dash panel near center console

Relay panel E-box 2

It is located on right under dash panel, near right a-pillar (only right-hand drive vehicles)

Engine compartment fuse box

The location of the fuses in the engine compartment: Volkswagen Touareg (2006-2010)

Fuse box diagram (Instrument Panel Fuse box, left)

Instrument panel fuse box diagram (left): Volkswagen Touareg (2006, 2007, 2008, 2009, 2010)

Assignment of the fuses in the left-side of the dash panel
AFunction/component
115
20 (Only auxiliary battery and two battery onboard supply)
U1 - Cigarette lighter
U9 - Rear cigarette lighter
25
15
J160 - Circulation pump relay (Only auxiliary battery and two battery onboard supply)
J708 - Residual heat relay (Only auxiliary battery and two battery onboard supply)
R149 - Remote control receiver for auxiliary coolant heater (Only auxiliary battery and two battery onboard supply)
U18 - 12 V socket 2 (Only one battery onboard supply)
U20 - 12 V socket 4 (Only one battery onboard supply)
315
20 (Only auxiliary battery and two battery onboard supply)
U5 - 12 V socket
U19 - 12 V socket 3
420J162 - Heater control unit
520U18 - 12 V socket 2 (Only auxiliary battery and two battery onboard supply)
U19 - 12 V socket 4 (Only auxiliary battery and two battery onboard supply)
J807 - Relay for power sockets (Only one battery onboard supply)
615J518 - Entry and start authorisation control unit (Only V10 TDI)
J708 - Residual heat relay (Only one battery onboard supply)
75T16b - Diagnostic connection
J515 - Aerial selection control unit
G397 - Rain and light detector sensor
825
30 (From November 2007)
V - Windscreen wiper motor
915J519 - Onboard supply control unit (windscreen wiper pump)
1025
30 (From November 2007)
J388 - Rear left door control unit (window regulator)
1115J386 - Driver door control unit (central locking)
J388 - Rear left door control unit (central locking)
1210J519 - Onboard supply control unit (interior light)
13-Not assigned
1425
30 (From November 2007)
J386 - Driver door control unit (window regulator)
1515J393 - Convenience system central control unit (right tail light cluster)
1620J519 - Onboard supply control unit (fanfare)
1730J519 - Onboard supply control unit (left light)
1820
25 (From November 2007)
J39 - Headlight washer system relay
19-Not assigned
2030J519 - Onboard supply control unit (battery 1)
21-Not assigned
2230J647 - Axle differential lock control unit
J605 - Rear lid control unit
2310J647 - Axle differential lock control unit
245J502 - Tyre pressure monitor control unit
2515J352 - Steering column and belt height adjustment control unit
2610F36 - Clutch pedal switch
J... - Engine control units
J234 - Airbag control unit
J285 - Control unit in dash panel insert
J519 - Onboard supply control unit
K145 - Front passenger side airbag deactivated warning lamp
N378 - Driver seat belt inertia reel magnet
N379 - Front passenger side seat inertia reel magnet
275E183 - Interior monitoring switch
W11 - Rear left reading light
W12 - Rear right reading light
W14 - Front passenger side illuminated vanity mirror
W20 - Driver side illuminated vanity mirror
W51 - Rear lid light
28-Not assigned
29-Not assigned
30-Not assigned
31-Not assigned
32-Not assigned
3315J527 - Steering column electronics control unit
345G273 - Interior monitoring sensor
G384 - Vehicle inclination sender
J285 - Control unit in dash panel insert (Only auxiliary battery and two battery onboard supply)
3530J519 - Onboard supply control unit
3630E470 - Driver seat adjustment operating unit
37-Not assigned
38-Not assigned
395J9 - Heated rear window relay
J32 - Air conditioning system relay
J329 - Terminal 15 voltage supply relay
J755 - Transport mode relay
J807 - Relay for power sockets (Only one battery onboard supply)
405J285 - Control unit in dash panel insert
4115J518 - Entry and start authorisation control unit
4230J245 - Sliding sunroof adjustment control unit
43-Not assigned
4430E470 - Driver seat adjustment operating unit
J136 - Seat and steering column adjustment control unit with memory
J810 - Driver seat adjustment control unit
46-Not assigned
4710J647 - Axle differential lock control unit
485J769 - Lane change assist control unit
J770 - Lane change assist control unit 2
495J236 - Servotronic control unit
5010G266 - Oil level and oil temperature sender
N79 - Crankcase breather heater element (Only models with engine codes BHK, BHL)
515T16b - Diagnostic connection
F321 - Parking brake contact switch
G238 - Air quality sensor
G550 - Sensor for automatic distance control
J755 - Transport mode relay
5230
15 (From November 2007)
V12 - Rear window wiper motor
535E1 - Light switch
J527 - Steering column electronics control unit
J393 - Convenience system central control unit
5410E102 - Headlight range control regulator (Only models with halogen headlights)
J667 - Power output module for left headlight (Only models with cornering light)
V48 - Left headlight range control motor (Only models with halogen headlights)
V49 - Right headlight range control motor (Only models with halogen headlights)
5515J486 - Fresh air blower relay for 2nd speed
5640J32 - Air conditioning system relay
J309 - Solar cell isolation relay
J486 - Fresh air blower relay, 2nd speed
SB55 - Fuse 55 on fuse holder B
V305 - Motor for front Bitron blower regulation
5740V306 - Motor for rear Bitron blower regulation (Up to November 2007)
J403 - Adaptive suspension compressor relay (From November 2007)

Fuse box diagram (Instrument Panel Fuse box, right)

Instrument panel fuse box diagram (right): Volkswagen Touareg (2006, 2007, 2008, 2009, 2010)

Assignment of the fuses in the right-side of the dash panel
AFunction/component
115
20 (From May 2008)
J345 - Trailer detector control unit
25J446 - Parking aid control unit
315J345 - Trailer detector control unit
45J412 - Mobile telephone operating electronics control unit
515
25 (From May 2008)
J345 - Trailer detector control unit
630J104 - ABS control unit
75J646 - Transfer box control unit
830J519 - Onboard supply control unit (right light)
910Individualisation
R190 - Satellite digital radio tuner (Only American markets)
105J772 - Reversing camera system control unit
R78 - TV tuner
1120J503 - Control unit with display for radio and navigation system
R - Radio
R - Preparation for radio and navigation system with TV (models for Japan)
1230R12 - Amplifier
13-Not assigned
1415J393 - Convenience system central control unit
1525
30 (From November 2007)
J389 - Rear right door control unit (window regulator)
1610
5 (From November 2007)
W3 - Luggage compartment light
17-Not assigned
1830J9 - Heated rear window relay
19-Not assigned
2030U13 - AC./DC converter with socket 12 V - 230 V
U27 - AC/DC converter with socket 12 V - 115 V (Only American markets)
2110F266 - Bonnet contact switch
2225J774 - Heated front seats control unit
2310J255 - Climatronic control unit
2430E471 - Front passenger seat adjustment operating unit
J521 - Front passenger seat adjustment with memory control unit
255E265 - Rear Climatronic operating and display unit
J301 - Air conditioning system control unit
26-Not assigned
2715J197 - Adaptive suspension control unit
28-Not assigned
2910
5 (From November 2007)
J217 - Automatic gearbox control unit
3020J714 - Power latching system relay
3115J393 - Convenience system central control unit
3210J387 - Front passenger door control unit (central locking)
J389 - Rear right door control unit (central locking)
3315Individualisation
3425
30 (From November 2007)
J387 - Front passenger side door control unit (window regulator)
3530E471 - Front passenger seat adjustment operating unit
365J603 - Vehicle position recognition control unit
J702 - Roof display unit
37-Not assigned
3810J104 - ABS control unit
395J410 - Heated windscreen relay for left side
J411 - Heated windscreen relay for right side
J745 - Cornering light and headlight range control unit
Individualisation
4010J646 - Transfer box control unit
4110J345 - Trailer detector control unit
425E284 - Garage door operating unit
J530 - Garage door operation control unit
435F41 - Reversing switch
445E94 - Heated driver seat regulator
E95 - Heated front passenger seat regulator
E128 - Heated rear left seat switch with regulator
E129 - Heated rear right seat switch with regulator
E281 - Operating unit to regulate suspension height
Z20 - Left washer jet heater element
Z21 - Right washer jet heater element
45-Not assigned
46-Not assigned
4710J668 - Power output module for right headlight
4810J197 - Adaptive suspension control unit
495Y7 - Automatic anti-dazzle interior mirror
505E256 - TCS and ESP button
5115J217 - Automatic gearbox control unit
525F125 - Multifunction switch
F189 - Tiptronic switch
N380 - Selector lever lock for position P solenoid
5330J411 - Heated windscreen relay for right side
5430J410 - Heated windscreen relay for left side
55-Not assigned
5640J104 - ABS control unit
5740J646 - Transfer box control unit

Fuse box diagram (Engine compartment (2.5L (R5) TDI engine))

Under-hood fuse box diagram: Volkswagen Touareg (2006, 2007, 2008, 2009, 2010)

Assignment of the fuses in the Engine compartment (2.5L (R5) TDI engine)
AFunction/component
160J293 - Radiator fan control unit
230J671 - Radiator fan control unit 2 (Only models for tropical climate zones and models with towing coupling)
3-Not assigned
4-Not assigned
5-Not assigned
6-Not assigned
7-Not assigned
8-Not assigned
930J623 - Engine control unit
1010G65 - High-pressure sender
J17 - Fuel pump relay
J255 - Climatronic control unit
J293 - Radiator fan control unit
J301 - Air conditioning system control unit
J445 - Fuel cooling pump relay
J496 - Additional coolant pump relay
J671 - Radiator fan control unit 2
N75 - Charge pressure control solenoid valve
N79 - Crankcase breather heater element
N280 - Air conditioner compressor regulating valve
N345 - Exhaust gas recirculation cooler changeover valve
11-Not assigned
1210J179 - Automatic glow period control unit
J496 - Additional coolant pump relay
1325G6 - Fuel system pressurisation pump
G23 - Fuel pump
J17 - Fuel pump relay
J445 - Fuel cooling pump relay
J715 - Tank circuit pressurisation relay
V166 - Fuel cooling pump
14-Not assigned
15-Not assigned
16-Not assigned
1710G39 - Lambda probe
Z19 - Lambda probe heater
18-Not assigned
Relays
A1Not assigned
A2Terminal 30 voltage supply relay -J317- (109)
A3Automatic glow period control unit -J179- (475)
A4Fuel pump relay -J17- (53)
A5Additional coolant pump relay -J496- (404)
A6Fuel cooling pump relay -J445- (404)
B1Not assigned
B2Not assigned
B3Not assigned
B3Not assigned
B4Not assigned
B5Not assigned
B6Not assigned
C19Tank circuit pressurisation relay -J715- (404) (Only auxiliary coolant heater)
C20Terminal 50 voltage supply relay -J682- (433)

Fuse box diagram (Engine compartment (3.0L (V6) diesel engine))

Assignment of the fuses in the Engine compartment (3.0L (V6) diesel engine))
AFunction/component
160
30 (Depends on equipment)
J293 - Radiator fan control unit
230J671 - Radiator fan control unit 2
3-Not assigned
480J360 - High heat output relay (Only models with engine code CATA)
540J359 - Low heat output relay (Only models with engine code CATA)
6-Not assigned
715N276 - Fuel pressure regulating valve
N290 - Fuel metering valve
J17 - Fuel pump relay (Only models with engine code CATA)
8-Not assigned
930J248 - Diesel direct injection system control unit
J623 - Engine control unit
1010G65 - High-pressure sender
J17 - Fuel pump relay
J179 - Automatic glow period control unit
J255 - Climatronic control unit
J293 - Radiator fan control unit
J301 - Air conditioning system control unit
J338 - Throttle valve module (Only models with engine code CATA)
J442 - Alternator cut-in relay (Up to May 2007)
J445 - Fuel cooling pump relay
J496 - Additional coolant pump relay
J671 - Radiator fan control unit 2
J724 - Turbocharger 1 control unit
J865 - Control unit for charge air cooler bypass (Only models with engine code CATA)
N18 - Exhaust gas recirculation valve
N280 - Air conditioner compressor regulating valve
N345 - Exhaust gas recirculation cooler changeover valve
N381 - Exhaust gas recirculation cooler changeover valve 2 (Only models with engine code CATA)
N428 - Valve block 2 in front passenger side rear seat (Only models with engine code CATA)
V157 - Intake manifold flap motor
V275 - Intake manifold flap 2 motor
V400 - Pump for exhaust gas recirculation cooler (Only models with engine code CATA)
1115 (Only models with engine code CATA)J445 - Fuel cooling pump relay
J832 - Relay for supplementary fuel pump
V166 - Fuel cooling pump
V393 - Supplementary fuel pump
1210J496 - Additional coolant pump relay
1325
20 (Only models with engine code CATA)
G6 - Fuel system pressurisation pump
G23 - Fuel pump
J17 - Fuel pump relay (Only models with engine code CATA)
J445 - Fuel cooling pump relay
J715 - Tank circuit pressurisation relay
V166 - Fuel cooling pump
1415G698 - Evaluation unit for reducing agent level (Only models with engine code CATA)
N473 - Reversing valve for reducing agent (Only models with engine code CATA)
V437 - Reducing agent pump (Only models with engine code CATA)
Z103 - Heater for reducing agent pump (Only models with engine code CATA)
1510J317 - Terminal 30 voltage supply relay
J623 - Engine control unit (Only models with engine code CATA)
1630J891 - Control unit for reducing agent heater
1720
15 (Depends on equipment)
J583 - NOx sensor control unit (Only models with engine code CATA)
J881 - NOx sensor 2 control unit (Only models with engine code CATA)
G39 - Lambda probe
Z19 - Lambda probe heater
18-Not assigned
Relays
A1Not assigned
A2Terminal 30 voltage supply relay -J317- (219) / (643) optional installation
A3Automatic glow period control unit -J179- (475) / (639) / (647) optional installation
A4Not assigned
A5Additional coolant pump relay -J496- (404 / (449) optional installation
A6Fuel cooling pump relay -J445- (404) / (449) optional installation
B1Not assigned
B2Fuel pump relay -J17- (53)
B3Not assigned
B3High heat output relay -J360- (100)
B4Low heat output relay -J359- (100)
B5Not assigned
B6Supplementary fuel pump relay -J832- (449)
C19Tank circuit pressurisation relay -J715- (404) (Only auxiliary coolant heater)
C20Terminal 50 voltage supply relay -J682- (433)

Fuse box diagram (Engine compartment (5.0L (V10) TDI engine))

Assignment of the fuses in the Engine compartment (5.0L (V10) TDI engine))
AFunction/component
160J293 - Radiator fan control unit
260 (Only models for tropical climate zones and models with towing coupling)
30
J671 - Radiator fan control unit 2
V177 - Radiator fan 2
3-Not assigned
4-Not assigned
5-Not assigned
660J701 - Voltage supply relay 1
710J708 - Residual heat relay
J496 - Additional coolant pump relay
J445 - Fuel cooling pump relay
V166 - Fuel cooling pump
830J624 - Engine control unit 2
930J623 - Engine control unit
1010G65 - High-pressure sender
J17 - Fuel pump relay
J293 - Radiator fan control unit
J671 - Radiator fan control unit 2
N345 - Exhaust gas recirculation cooler changeover valve
N381 - Exhaust gas recirculation cooler changeover valve 2
V336 - Metering pump for post-injection in particulate filter for cylinder bank 1 (Only American markets)
V337 - Metering pump for post-injection in particulate filter for cylinder bank 2 (Only American markets)
1115F265 - Map-controlled engine cooling system thermostat
J255 - Climatronic control unit
J724 - Turbocharger 1 control unit
J725 - Turbocharger 2 control unit
N280 - Air conditioner compressor regulating valve
V135 - Particulate filter additive pump (Only American markets)
V157 - Intake manifold flap motor
V275 - Intake manifold flap 2 motor
V280 - Turbocharger 1 control motor
V281 - Turbocharger 2 control motor
125J179 - Automatic glow period control unit
J445 - Fuel cooling pump relay
J496 - Additional coolant pump relay
J703 - Glow period control unit 2
1325 (Not American markets)
30
G6 - Fuel system pressurisation pump
G23 - Fuel pump
J17 - Fuel pump relay
J715 - Tank circuit pressurisation relay (Not American markets)
14-Not assigned
1510J317 - Terminal 30 voltage supply relay
1610J581 - Battery parallel circuit relay
1720G39 - Lambda probe
G108 - Lambda probe 2
Z19 - Lambda probe heater
Z28 - Lambda probe heater 2
18-Not assigned
Relays
A1Glow period control unit 2 -J703- (475)
A2Terminal 30 voltage supply relay 2 -J689- (219)
A3Automatic glow period control unit -J179- (475)
A4Not assigned
A5Additional coolant pump relay -J496- (404)
A6Fuel cooling pump relay -J445- (404)
B1Terminal 30 voltage supply relay -J317- (219)
B2Fuel pump relay -J17- (53)
B3Not assigned
B3Not assigned
B4Voltage supply relay 1-J701- (100) / (370) optional installation
B5Not assigned
B6Not assigned
C19Tank circuit pressurisation relay -J715- (404) (Not for American markets)
C20Terminal 50 voltage supply relay -J682- (433)

Fuse box diagram (Engine compartment (3.2L (V6) petrol engine))

Assignment of the fuses in the Engine compartment (3.2L (V6) petrol engine)
AFunction/component
160J293 - Radiator fan control unit
230J671 - Radiator fan control unit 2
340V101 - Secondary air pump motor
4-Not assigned
5-Not assigned
6-Not assigned
720N30 - Injector, cylinder 1
N31 - Injector, cylinder 2
N32 - Injector, cylinder 3
N70 - Ignition coil 1 with power output stage
N127 - Ignition coil 2 with power output stage
N291 - Ignition coil 3 with power output stage
820N33 - Injector, cylinder 4
N83 - Injector, cylinder 5
N84 - Injector, cylinder 6
N292 - Ignition coil 4 with power output stage
N323 - Ignition coil 5 with power output stage
N324 - Ignition coil 6 with power output stage
930J220 - Motronic control unit
N156 - Variable intake manifold changeover valve
N205 - Inlet camshaft control valve 1
N318 - Exhaust camshaft control valve 1
1010G65 - High-pressure sender
J293 - Radiator fan control unit
J569 - Brake servo relay
J671 - Radiator fan control unit 2
N80 - Activated charcoal filter solenoid valve 1
N115 - Activated charcoal filter solenoid valve 2
V144 - Fuel system diagnostic pump
1115G266 - Oil level and oil temperature sender
J255 - Climatronic control unit
N280 - Air conditioner compressor regulating valve
125J299 - Secondary air pump relay
J496 - Additional coolant pump relay
1315G23 - Fuel pump
1415G6 - Fuel system pressurisation pump
1510J17 - Fuel pump relay
J49 - Electric fuel pump 2 relay
J220 - Motronic control unit
J271 - Motronic current supply relay
J670 - Motronic current supply relay 2
1615V192 - Vacuum pump for brakes
1715G39 - Lambda probe
G108 - Lambda probe 2
187.5G130 - Lambda probe after catalytic converter
G131 - Lambda probe 2 after catalytic converter
Relays
A1Terminal 30 voltage supply relay 2 -J689- (53)
A2Not assigned
A3Terminal 30 voltage supply relay -J317- (167
A4Secondary air pump relay -J299- (100) / (370) optional installation
A5Additional coolant pump relay -J496- (404)
A6Fuel pump relay -J17- (53)
B1Not assigned
B2Not assigned
B3Not assigned
B3Not assigned
B4Not assigned
B5Not assigned
B6Brake servo relay -J569- (404) (Only models with automatic gearbox)
C19Electric fuel pump 2 relay -J49- (404)
C20Terminal 50 voltage supply relay -J682- (433)

Fuse box diagram (Engine compartment (3.6L (V6) FSI engine))

Assignment of the fuses in the Engine compartment (3.6L (V6) FSI engine)
AFunction/component
160J293 - Radiator fan control unit
230 (Only models for tropical climate zones and models with towing coupling)J671 - Radiator fan control unit 2
V7 - Radiator fan
3-Not assigned
4-Not assigned
5-Not assigned
6-Not assigned
720N70 - Ignition coil 1 with output stage
N127 - Ignition coil 2 with output stage
N291 - Ignition coil 3 with output stage
820N292 - Ignition coil 4 with output stage
N323 - Ignition coil 5 with output stage
N324 - Ignition coil 6 with output stage
930J623 - Engine control unit
1010G65 - High-pressure sender
J293 - Radiator fan control unit
J496 - Additional coolant pump relay
J671 - Radiator fan control unit 2 (Only models for tropical climate zones and models with towing coupling)
V144 - Fuel system diagnostic pump
1110J255 - Climatronic control unit
J301 - Air conditioning system control unit
J442 - Alternator cut-in relay2)
N280 - Air conditioner compressor regulating valve
1210N80 - Activated charcoal filter system solenoid valve 1
N205 - Inlet camshaft control valve 1
N316 - Intake manifold flap valve
N318 - Exhaust camshaft control valve 1
1325J538 - Fuel pump control unit
1415N276 - Fuel pressure regulating valve
1510J623 - Engine control unit
J271 - Motronic current supply relay
J670 - Motronic current supply relay 2
1615J496 - Additional coolant pump relay
1715G39 - Lambda probe
G108 - Lambda probe 2
Z19 - Lambda probe heater
Z28 - Lambda probe heater 2
187.5G130 - Lambda probe after catalytic converter
G131 - Lambda probe 2 after catalytic converter
Z29 - Lambda probe 1 heater after catalytic converter
Z30 - Lambda probe 2 heater after catalytic converter
Relays
A1Not assigned
A2Not assigned
A3Motronic current supply relay -J271- (614)
A4Not assigned
A5Additional coolant pump relay -J496- (404)
A6Not assigned
B1Not assigned
B2Not assigned
B3Not assigned
B3Not assigned
B4Motronic current supply relay 2 -J670- (614) to May 2007
B5Not assigned
B6Not assigned
C19Not assigned
C20Terminal 50 voltage supply relay -J682- (433)

Fuse box diagram (Engine compartment (4.2L (V8) FSI engine))

Assignment of the fuses in the Engine compartment (4.2L (V8) FSI engine)
AFunction/component
160J671 - Radiator fan control unit 2
V177 - Radiator fan 2
260 (Only models with towing coupling)
30
J293 - Radiator fan control unit
V7 - Radiator fan
340J299 - Secondary air pump relay V101 - Secondary air pump motor
4-Not assigned
5-Not assigned
6-Not assigned
720N70 - Ignition coil 1 with output stage
N127 - Ignition coil 2 with output stage
N291 - Ignition coil 3 with output stage
N292 - Ignition coil 4 with output stage
N323 - Ignition coil 5 with output stage
N324 - Ignition coil 6 with output stage
N325 - Ignition coil 7 with output stage
N326 - Ignition coil 8 with output stage
8-Not assigned
930J623 - Engine control unit
1010G70 - Air mass meter
G246 - Air mass meter 2
J299 - Secondary air pump relay
N80 - Activated charcoal filter solenoid valve 1
V144 - Fuel system diagnostic pump
11-Not assigned
1220F265 - Map-controlled engine cooling system thermostat
G65 - High-pressure sender
J151 - Continued coolant circulation relay
J255 - Climatronic control unit
J301 - Air conditioning system control unit
J293 - Radiator fan control unit
J442 - Alternator cut-in relay (Up to May 2007)
J671 - Radiator fan control unit 2
N205 - Inlet camshaft control valve 1
N208 - Inlet camshaft control valve 2
N280 - Air conditioner compressor regulating valve
N318 - Exhaust camshaft control valve 1
N319 - Exhaust camshaft control valve 2
V157 - Intake manifold flap motor
V183 - Variable intake manifold motor
1325J538 - Fuel pump control unit
1410N290 - Fuel metering valve
N402 - Fuel metering valve 2
1510J271 - Motronic current supply relay
J623 - Engine control unit
1615J569 - Brake servo relay
V192 - Vacuum pump for brakes
1710G39 - Lambda probe
G108 - Lambda probe 2
1810G130 - Lambda probe after catalytic converter
G131 - Lambda probe 2 after catalytic converter
Relays
A1Not assigned
A2Not assigned
A3Automatic glow period control unit -J179- (475)
A4Secondary air pump relay -J299- (100) / (370) optional installation
A5Continued coolant circulation relay -J151- (404)
A6Not assigned
B1Not assigned
B2Not assigned
B3Not assigned
B3Not assigned
B4Engine components current supply relay -J757- (614)
B5Not assigned
B6Brake servo relay -J569- (404) (Only models with automatic gearbox)
C19Not assigned
C20Terminal 50 voltage supply relay -J682- (433)

Fuse box diagram (Engine compartment (6.0L (W12) petrol engine))

Assignment of the fuses in the Engine compartment (6.0L (W12) petrol engine)
AFunction/component
160J671 - Radiator fan control unit 2
V177 - Radiator fan 2
260 (Only models with towing coupling)
30
J293 - Radiator fan control unit
V7 - Radiator fan
340J299 - Secondary air pump relay
V101 - Secondary air pump motor
440J545 - Secondary air pump relay 2
V189 - Secondary air pump motor 2
530N325 - Ignition coil 7 with output stage
N326 - Ignition coil 8 with output stage
N327 - Ignition coil 9 with output stage
N328 - Ignition coil 10 with output stage
N329 - Ignition coil 11 with output stage
N330 - Ignition coil 12 with output stage
S7 - Fuse in relay plate fuse holder
630N70 - Ignition coil 1 with output stage
N127 - Ignition coil 2 with output stage
N291 - Ignition coil 3 with output stage
N292 - Ignition coil 4 with output stage
N323 - Ignition coil 5 with output stage
N324 - Ignition coil 6 with output stage
S8 - Fuse in relay plate fuse holder
710N85 - Injector, cylinder 7
N86 - Injector, cylinder 8
N299 - Injector, cylinder 9
N300 - Injector, cylinder 10
N301 - Injector, cylinder 11
N302 - Injector, cylinder 12
810N30 - Injector, cylinder 1
N31 - Injector, cylinder 2
N32 - Injector, cylinder 3
N33 - Injector, cylinder 4
N83 - Injector, cylinder 5
N84 - Injector, cylinder 6
930J623 - Engine control unit
J624 - Engine control unit 2
1010G65 - High-pressure sender
J255 - Climatronic control unit
J293 - Radiator fan control unit
J301 - Air conditioning system control unit
J442 - Alternator cut-in relay (Up to May 2007)
J671 - Radiator fan control unit 2
V144 - Fuel system diagnostic pump
1115N80 - Activated charcoal filter solenoid valve 1
N205 - Inlet camshaft control valve 1
N208 - Inlet camshaft control valve 2
N280 - Air conditioner compressor regulating valve
N318 - Exhaust camshaft control valve 1
N319 - Exhaust camshaft control valve 2
125J49 - Electric fuel pump 2 relay
J299 - Secondary air pump relay
J545 - Secondary air pump relay 2
J624 - Engine control unit 2
1315G6 - Fuel system pressurisation pump
J17 - Fuel pump relay
1415G23 - Fuel pump
J49 - Electric fuel pump 2 relay
1510J17 - Fuel pump relay
J271 - Motronic current supply relay
J623 - Engine control unit
J624 - Engine control unit 2
1615J496 - Additional coolant pump relay
J569 - Brake servo relay
V51 - Continued coolant circulation pump
V192 - Vacuum pump for brakes
1730G39 - Lambda probe
G108 - Lambda probe 2
G285 - Lambda probe 3
G286 - Lambda probe 4
Z19 - Lambda probe heater
Z28 - Lambda probe heater 2
Z62 - Lambda probe heater 3
Z63 - Lambda probe heater 4
1815G130 - Lambda probe after catalytic converter
G131 - Lambda probe 2 after catalytic converter
G287 - Lambda probe 3 after catalytic converter
G288 - Lambda probe 4 after catalytic converter
Z29 - Lambda probe 1 heater after catalytic converter
Z30 - Lambda probe 2 heater after catalytic converter
Z64 - Lambda probe 3 heater after catalytic converter
Z65 - Lambda probe 4 heater after catalytic converter
Relays
A1Not assigned
A2Not assigned
A3Motronic current supply relay -J271- (100) / (370) optional installation
A4Secondary air pump relay -J299- (100) / (370) optional installation
A5Additional coolant pump relay -J496- (404)
A6Electric fuel pump 2 relay -J49- (404)
B1Not assigned
B2Not assigned
B3Not assigned
B3Secondary air pump relay 2 -J545- (100) / (370) optional installation
B4Not assigned
B5Not assigned
B6Brake servo relay -J569- (404) (Only models with automatic gearbox)
C19Fuel pump relay -J17- (404)
C20Terminal 50 voltage supply relay -J682- (433)

Pre-fuse box (under driver seat)

Pre-fuse box: Volkswagen Touareg (2006, 2007, 2008, 2009, 2010)

Pre-fuse box (under driver seat)
AFunction/component
SD1150Left fuse carrier
SD2150Right fuse carrier
SD360Right fuse carrier
SD460
40 (From November 2007)
J701 - Voltage supply relay 2 (Only V10 TDI)
V306 - Motor for rear Bitron blower regulation (From November 2007)
SD560
40 (From November 2007)
J329 - Terminal 15 voltage supply relay
SD6-Not assigned
SD7250J713 - Charger relay for second battery
SD8150 (Only V10 TDI)
60 (Only models with additional battery)
Left fuse carrier
J701 - Voltage supply relay 1 (Only V10 TDI)
SD95J519 - Onboard supply control unit
SD1010
5 (From November 2007)
J519 - Onboard supply control unit (Only V10 TDI)
SD115J519 - Onboard supply control unit (Only V10 TDI)
SD12-Not assigned
SD1340J403 - Adaptive suspension compressor relay
V306 - Motor for rear Bitron blower regulation (Only V10 TDI) (From November 2007)
SD14-Not assigned
Relays
1Battery master/isolator switch -E74-
2Terminal 15 voltage supply relay -J329- (433)
3Second battery charging circuit relay -J713-

Relay panel E-Box 1 (on left under dash panel near center console)

Relay panel 1: Volkswagen Touareg (2006, 2007, 2008, 2009, 2010)

Relay panel E-Box 1 (on left under dash panel near center console)
Function/component
D1Servotronic control unit -J236- (476)
D2Power latching system relay -J714- (404)
D3Adaptive suspension compressor relay -J403- (373)
D4Power sockets relay -J807- (404)
D5Air conditioning system relay -J32- (100) / (370) optional installation
D6Fresh air blower relay, 2nd speed -J486- (404), only manually operated air conditioning system
D7Heated rear window relay -J9- (53)
D8Circulation pump relay -J160- (404), only VR6 with auxiliary heater
D9Alternator cut-in relay -J442- (53)
E1Solar cells isolation relay -J309- (79)
E2Not assigned
E3Heated windscreen relay for left side -J410- (53)
E4Not assigned
E5Voltage supply relay 2 -J710- (432), only V10 TDI
E6Not assigned
E7Headlight washer system relay -J39- (53)
E8Residual heat relay -J708- (404)
E9Heated windscreen relay for right side -J411- (53)

Relay panel E-box 2 (on right under dash panel, near right a-pillar)

Relay panel 2: Volkswagen Touareg (2006, 2007, 2008, 2009, 2010)

Relay panel E-box 2 (on right under dash panel, near right a-pillar)
Function/component
D1Servotronic control unit -J236- (476)
D2Power latching system relay -J714- (404)
D3Adaptive suspension compressor relay -J403- (373)
D4Power sockets relay -J807- (404)
D5Air conditioning system relay -J32- (100) / (370) optional installation
D6Fresh air blower relay, 2nd speed -J486- (404), only manually operated air conditioning system
D7Heated rear window relay -J9- (53)
D8Circulation pump relay -J160- (404), only VR6 with auxiliary heater
D9Alternator cut-in relay -J442- (53)
E1Solar cells isolation relay -J309- (79)
E2Residual heat relay -J708- (404)
E3Heated windscreen relay for left side -J410- (53)
E4Voltage supply relay 2 -J710- (432), only V10 TDI
E5Heated windscreen relay for right side -J411- (53)
E6Headlight washer system relay -J39- (53)
Volkswagen Touareg (2006-2010) fuses and relays December 19, 2018 admin