Advertisements
In this article, we consider the first-generation Volkswagen Touareg (7L) after a facelift, produced from 2006 to 2010. Here you will find fuse box diagrams of Volkswagen Touareg 2006, 2007, 2008, 2009 and 2010, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
See other Volkswagen Touareg:
Fuse Layout Volkswagen Touareg 2006-2010
Cigar lighter (power outlet) fuses in the Volkswagen Touareg are the fuses #1, #2, #3 and #5 in the Left Instrument panel fuse box.
Table of Contents
Fuse box location
Fuse box location
Fuse holder on the left side edge of the instrument panel
Fuse holder on the right side edge of the instrument panel
Pre-fuse box, under driver seat
Located near the battery under the driver seat
Relay panel E-Box 1
It is located on left under dash panel near center console
Relay panel E-box 2
It is located on right under dash panel, near right a-pillar (only right-hand drive vehicles)
Engine compartment fuse box
Fuse box diagrams
Fuse box diagrams
Instrument Panel, left
Advertisements
Assignment of the fuses in the left-side of the dash panel
| № | A | Function/component |
|---|---|---|
| 1 | 15 20 (Only auxiliary battery and two battery onboard supply) | U1 - Cigarette lighter U9 - Rear cigarette lighter |
| 2 | 5 15 | J160 - Circulation pump relay (Only auxiliary battery and two battery onboard supply) J708 - Residual heat relay (Only auxiliary battery and two battery onboard supply) R149 - Remote control receiver for auxiliary coolant heater (Only auxiliary battery and two battery onboard supply) U18 - 12 V socket 2 (Only one battery onboard supply) U20 - 12 V socket 4 (Only one battery onboard supply) |
| 3 | 15 20 (Only auxiliary battery and two battery onboard supply) | U5 - 12 V socket U19 - 12 V socket 3 |
| 4 | 20 | J162 - Heater control unit |
| 5 | 20 | U18 - 12 V socket 2 (Only auxiliary battery and two battery onboard supply) U19 - 12 V socket 4 (Only auxiliary battery and two battery onboard supply) J807 - Relay for power sockets (Only one battery onboard supply) |
| 6 | 15 | J518 - Entry and start authorisation control unit (Only V10 TDI) J708 - Residual heat relay (Only one battery onboard supply) |
| 7 | 5 | T16b - Diagnostic connection J515 - Aerial selection control unit G397 - Rain and light detector sensor |
| 8 | 25 30 (From November 2007) | V - Windscreen wiper motor |
| 9 | 15 | J519 - Onboard supply control unit (windscreen wiper pump) |
| 10 | 25 30 (From November 2007) | J388 - Rear left door control unit (window regulator) |
| 11 | 15 | J386 - Driver door control unit (central locking) J388 - Rear left door control unit (central locking) |
| 12 | 10 | J519 - Onboard supply control unit (interior light) |
| 13 | - | Not assigned |
| 14 | 25 30 (From November 2007) | J386 - Driver door control unit (window regulator) |
| 15 | 15 | J393 - Convenience system central control unit (right tail light cluster) |
| 16 | 20 | J519 - Onboard supply control unit (fanfare) |
| 17 | 30 | J519 - Onboard supply control unit (left light) |
| 18 | 20 25 (From November 2007) | J39 - Headlight washer system relay |
| 19 | - | Not assigned |
| 20 | 30 | J519 - Onboard supply control unit (battery 1) |
| 21 | - | Not assigned |
| 22 | 30 | J647 - Axle differential lock control unit J605 - Rear lid control unit |
| 23 | 10 | J647 - Axle differential lock control unit |
| 24 | 5 | J502 - Tyre pressure monitor control unit |
| 25 | 15 | J352 - Steering column and belt height adjustment control unit |
| 26 | 10 | F36 - Clutch pedal switch J... - Engine control units J234 - Airbag control unit J285 - Control unit in dash panel insert J519 - Onboard supply control unit K145 - Front passenger side airbag deactivated warning lamp N378 - Driver seat belt inertia reel magnet N379 - Front passenger side seat inertia reel magnet |
| 27 | 5 | E183 - Interior monitoring switch W11 - Rear left reading light W12 - Rear right reading light W14 - Front passenger side illuminated vanity mirror W20 - Driver side illuminated vanity mirror W51 - Rear lid light |
| 28 | - | Not assigned |
| 29 | - | Not assigned |
| 30 | - | Not assigned |
| 31 | - | Not assigned |
| 32 | - | Not assigned |
| 33 | 15 | J527 - Steering column electronics control unit |
| 34 | 5 | G273 - Interior monitoring sensor G384 - Vehicle inclination sender J285 - Control unit in dash panel insert (Only auxiliary battery and two battery onboard supply) |
| 35 | 30 | J519 - Onboard supply control unit |
| 36 | 30 | E470 - Driver seat adjustment operating unit |
| 37 | - | Not assigned |
| 38 | - | Not assigned |
| 39 | 5 | J9 - Heated rear window relay J32 - Air conditioning system relay J329 - Terminal 15 voltage supply relay J755 - Transport mode relay J807 - Relay for power sockets (Only one battery onboard supply) |
| 40 | 5 | J285 - Control unit in dash panel insert |
| 41 | 15 | J518 - Entry and start authorisation control unit |
| 42 | 30 | J245 - Sliding sunroof adjustment control unit |
| 43 | - | Not assigned |
| 44 | 30 | E470 - Driver seat adjustment operating unit J136 - Seat and steering column adjustment control unit with memory J810 - Driver seat adjustment control unit |
| 46 | - | Not assigned |
| 47 | 10 | J647 - Axle differential lock control unit |
| 48 | 5 | J769 - Lane change assist control unit J770 - Lane change assist control unit 2 |
| 49 | 5 | J236 - Servotronic control unit |
| 50 | 10 | G266 - Oil level and oil temperature sender N79 - Crankcase breather heater element (Only models with engine codes BHK, BHL) |
| 51 | 5 | T16b - Diagnostic connection F321 - Parking brake contact switch G238 - Air quality sensor G550 - Sensor for automatic distance control J755 - Transport mode relay |
| 52 | 30 15 (From November 2007) | V12 - Rear window wiper motor |
| 53 | 5 | E1 - Light switch J527 - Steering column electronics control unit J393 - Convenience system central control unit |
| 54 | 10 | E102 - Headlight range control regulator (Only models with halogen headlights) J667 - Power output module for left headlight (Only models with cornering light) V48 - Left headlight range control motor (Only models with halogen headlights) V49 - Right headlight range control motor (Only models with halogen headlights) |
| 55 | 15 | J486 - Fresh air blower relay for 2nd speed |
| 56 | 40 | J32 - Air conditioning system relay J309 - Solar cell isolation relay J486 - Fresh air blower relay, 2nd speed SB55 - Fuse 55 on fuse holder B V305 - Motor for front Bitron blower regulation |
| 57 | 40 | V306 - Motor for rear Bitron blower regulation (Up to November 2007) J403 - Adaptive suspension compressor relay (From November 2007) |
Advertisements
Instrument Panel, right
| № | A | Function/component |
|---|---|---|
| 1 | 15 20 (From May 2008) | J345 - Trailer detector control unit |
| 2 | 5 | J446 - Parking aid control unit |
| 3 | 15 | J345 - Trailer detector control unit |
| 4 | 5 | J412 - Mobile telephone operating electronics control unit |
| 5 | 15 25 (From May 2008) | J345 - Trailer detector control unit |
| 6 | 30 | J104 - ABS control unit |
| 7 | 5 | J646 - Transfer box control unit |
| 8 | 30 | J519 - Onboard supply control unit (right light) |
| 9 | 10 | Individualisation R190 - Satellite digital radio tuner (Only American markets) |
| 10 | 5 | J772 - Reversing camera system control unit R78 - TV tuner |
| 11 | 20 | J503 - Control unit with display for radio and navigation system R - Radio R - Preparation for radio and navigation system with TV (models for Japan) |
| 12 | 30 | R12 - Amplifier |
| 13 | - | Not assigned |
| 14 | 15 | J393 - Convenience system central control unit |
| 15 | 25 30 (From November 2007) | J389 - Rear right door control unit (window regulator) |
| 16 | 10 5 (From November 2007) | W3 - Luggage compartment light |
| 17 | - | Not assigned |
| 18 | 30 | J9 - Heated rear window relay |
| 19 | - | Not assigned |
| 20 | 30 | U13 - AC./DC converter with socket 12 V - 230 V U27 - AC/DC converter with socket 12 V - 115 V (Only American markets) |
| 21 | 10 | F266 - Bonnet contact switch |
| 22 | 25 | J774 - Heated front seats control unit |
| 23 | 10 | J255 - Climatronic control unit |
| 24 | 30 | E471 - Front passenger seat adjustment operating unit J521 - Front passenger seat adjustment with memory control unit |
| 25 | 5 | E265 - Rear Climatronic operating and display unit J301 - Air conditioning system control unit |
| 26 | - | Not assigned |
| 27 | 15 | J197 - Adaptive suspension control unit |
| 28 | - | Not assigned |
| 29 | 10 5 (From November 2007) | J217 - Automatic gearbox control unit |
| 30 | 20 | J714 - Power latching system relay |
| 31 | 15 | J393 - Convenience system central control unit |
| 32 | 10 | J387 - Front passenger door control unit (central locking) J389 - Rear right door control unit (central locking) |
| 33 | 15 | Individualisation |
| 34 | 25 30 (From November 2007) | J387 - Front passenger side door control unit (window regulator) |
| 35 | 30 | E471 - Front passenger seat adjustment operating unit |
| 36 | 5 | J603 - Vehicle position recognition control unit J702 - Roof display unit |
| 37 | - | Not assigned |
| 38 | 10 | J104 - ABS control unit |
| 39 | 5 | J410 - Heated windscreen relay for left side J411 - Heated windscreen relay for right side J745 - Cornering light and headlight range control unit Individualisation |
| 40 | 10 | J646 - Transfer box control unit |
| 41 | 10 | J345 - Trailer detector control unit |
| 42 | 5 | E284 - Garage door operating unit J530 - Garage door operation control unit |
| 43 | 5 | F41 - Reversing switch |
| 44 | 5 | E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator E128 - Heated rear left seat switch with regulator E129 - Heated rear right seat switch with regulator E281 - Operating unit to regulate suspension height Z20 - Left washer jet heater element Z21 - Right washer jet heater element |
| 45 | - | Not assigned |
| 46 | - | Not assigned |
| 47 | 10 | J668 - Power output module for right headlight |
| 48 | 10 | J197 - Adaptive suspension control unit |
| 49 | 5 | Y7 - Automatic anti-dazzle interior mirror |
| 50 | 5 | E256 - TCS and ESP button |
| 51 | 15 | J217 - Automatic gearbox control unit |
| 52 | 5 | F125 - Multifunction switch F189 - Tiptronic switch N380 - Selector lever lock for position P solenoid |
| 53 | 30 | J411 - Heated windscreen relay for right side |
| 54 | 30 | J410 - Heated windscreen relay for left side |
| 55 | - | Not assigned |
| 56 | 40 | J104 - ABS control unit |
| 57 | 40 | J646 - Transfer box control unit |
Advertisements
Engine compartment (2.5L (R5) TDI engine)
| № | A | Function/component |
|---|---|---|
| 1 | 60 | J293 - Radiator fan control unit |
| 2 | 30 | J671 - Radiator fan control unit 2 (Only models for tropical climate zones and models with towing coupling) |
| 3 | - | Not assigned |
| 4 | - | Not assigned |
| 5 | - | Not assigned |
| 6 | - | Not assigned |
| 7 | - | Not assigned |
| 8 | - | Not assigned |
| 9 | 30 | J623 - Engine control unit |
| 10 | 10 | G65 - High-pressure sender J17 - Fuel pump relay J255 - Climatronic control unit J293 - Radiator fan control unit J301 - Air conditioning system control unit J445 - Fuel cooling pump relay J496 - Additional coolant pump relay J671 - Radiator fan control unit 2 N75 - Charge pressure control solenoid valve N79 - Crankcase breather heater element N280 - Air conditioner compressor regulating valve N345 - Exhaust gas recirculation cooler changeover valve |
| 11 | - | Not assigned |
| 12 | 10 | J179 - Automatic glow period control unit J496 - Additional coolant pump relay |
| 13 | 25 | G6 - Fuel system pressurisation pump G23 - Fuel pump J17 - Fuel pump relay J445 - Fuel cooling pump relay J715 - Tank circuit pressurisation relay V166 - Fuel cooling pump |
| 14 | - | Not assigned |
| 15 | - | Not assigned |
| 16 | - | Not assigned |
| 17 | 10 | G39 - Lambda probe Z19 - Lambda probe heater |
| 18 | - | Not assigned |
| Relays | ||
| A1 | Not assigned | |
| A2 | Terminal 30 voltage supply relay -J317- (109) | |
| A3 | Automatic glow period control unit -J179- (475) | |
| A4 | Fuel pump relay -J17- (53) | |
| A5 | Additional coolant pump relay -J496- (404) | |
| A6 | Fuel cooling pump relay -J445- (404) | |
| B1 | Not assigned | |
| B2 | Not assigned | |
| B3 | Not assigned | |
| B3 | Not assigned | |
| B4 | Not assigned | |
| B5 | Not assigned | |
| B6 | Not assigned | |
| C19 | Tank circuit pressurisation relay -J715- (404) (Only auxiliary coolant heater) | |
| C20 | Terminal 50 voltage supply relay -J682- (433) |
Engine compartment (3.0L (V6) diesel engine)
Advertisements
Assignment of the fuses in the Engine compartment (3.0L (V6) diesel engine))
| № | A | Function/component |
|---|---|---|
| 1 | 60 30 (Depends on equipment) | J293 - Radiator fan control unit |
| 2 | 30 | J671 - Radiator fan control unit 2 |
| 3 | - | Not assigned |
| 4 | 80 | J360 - High heat output relay (Only models with engine code CATA) |
| 5 | 40 | J359 - Low heat output relay (Only models with engine code CATA) |
| 6 | - | Not assigned |
| 7 | 15 | N276 - Fuel pressure regulating valve N290 - Fuel metering valve J17 - Fuel pump relay (Only models with engine code CATA) |
| 8 | - | Not assigned |
| 9 | 30 | J248 - Diesel direct injection system control unit J623 - Engine control unit |
| 10 | 10 | G65 - High-pressure sender J17 - Fuel pump relay J179 - Automatic glow period control unit J255 - Climatronic control unit J293 - Radiator fan control unit J301 - Air conditioning system control unit J338 - Throttle valve module (Only models with engine code CATA) J442 - Alternator cut-in relay (Up to May 2007) J445 - Fuel cooling pump relay J496 - Additional coolant pump relay J671 - Radiator fan control unit 2 J724 - Turbocharger 1 control unit J865 - Control unit for charge air cooler bypass (Only models with engine code CATA) N18 - Exhaust gas recirculation valve N280 - Air conditioner compressor regulating valve N345 - Exhaust gas recirculation cooler changeover valve N381 - Exhaust gas recirculation cooler changeover valve 2 (Only models with engine code CATA) N428 - Valve block 2 in front passenger side rear seat (Only models with engine code CATA) V157 - Intake manifold flap motor V275 - Intake manifold flap 2 motor V400 - Pump for exhaust gas recirculation cooler (Only models with engine code CATA) |
| 11 | 15 (Only models with engine code CATA) | J445 - Fuel cooling pump relay J832 - Relay for supplementary fuel pump V166 - Fuel cooling pump V393 - Supplementary fuel pump |
| 12 | 10 | J496 - Additional coolant pump relay |
| 13 | 25 20 (Only models with engine code CATA) | G6 - Fuel system pressurisation pump G23 - Fuel pump J17 - Fuel pump relay (Only models with engine code CATA) J445 - Fuel cooling pump relay J715 - Tank circuit pressurisation relay V166 - Fuel cooling pump |
| 14 | 15 | G698 - Evaluation unit for reducing agent level (Only models with engine code CATA) N473 - Reversing valve for reducing agent (Only models with engine code CATA) V437 - Reducing agent pump (Only models with engine code CATA) Z103 - Heater for reducing agent pump (Only models with engine code CATA) |
| 15 | 10 | J317 - Terminal 30 voltage supply relay J623 - Engine control unit (Only models with engine code CATA) |
| 16 | 30 | J891 - Control unit for reducing agent heater |
| 17 | 20 15 (Depends on equipment) | J583 - NOx sensor control unit (Only models with engine code CATA) J881 - NOx sensor 2 control unit (Only models with engine code CATA) G39 - Lambda probe Z19 - Lambda probe heater |
| 18 | - | Not assigned |
| Relays | ||
| A1 | Not assigned | |
| A2 | Terminal 30 voltage supply relay -J317- (219) / (643) optional installation | |
| A3 | Automatic glow period control unit -J179- (475) / (639) / (647) optional installation | |
| A4 | Not assigned | |
| A5 | Additional coolant pump relay -J496- (404 / (449) optional installation | |
| A6 | Fuel cooling pump relay -J445- (404) / (449) optional installation | |
| B1 | Not assigned | |
| B2 | Fuel pump relay -J17- (53) | |
| B3 | Not assigned | |
| B3 | High heat output relay -J360- (100) | |
| B4 | Low heat output relay -J359- (100) | |
| B5 | Not assigned | |
| B6 | Supplementary fuel pump relay -J832- (449) | |
| C19 | Tank circuit pressurisation relay -J715- (404) (Only auxiliary coolant heater) | |
| C20 | Terminal 50 voltage supply relay -J682- (433) |
Advertisements
Engine compartment (5.0L (V10) TDI engine)
| № | A | Function/component |
|---|---|---|
| 1 | 60 | J293 - Radiator fan control unit |
| 2 | 60 (Only models for tropical climate zones and models with towing coupling) 30 | J671 - Radiator fan control unit 2 V177 - Radiator fan 2 |
| 3 | - | Not assigned |
| 4 | - | Not assigned |
| 5 | - | Not assigned |
| 6 | 60 | J701 - Voltage supply relay 1 |
| 7 | 10 | J708 - Residual heat relay J496 - Additional coolant pump relay J445 - Fuel cooling pump relay V166 - Fuel cooling pump |
| 8 | 30 | J624 - Engine control unit 2 |
| 9 | 30 | J623 - Engine control unit |
| 10 | 10 | G65 - High-pressure sender J17 - Fuel pump relay J293 - Radiator fan control unit J671 - Radiator fan control unit 2 N345 - Exhaust gas recirculation cooler changeover valve N381 - Exhaust gas recirculation cooler changeover valve 2 V336 - Metering pump for post-injection in particulate filter for cylinder bank 1 (Only American markets) V337 - Metering pump for post-injection in particulate filter for cylinder bank 2 (Only American markets) |
| 11 | 15 | F265 - Map-controlled engine cooling system thermostat J255 - Climatronic control unit J724 - Turbocharger 1 control unit J725 - Turbocharger 2 control unit N280 - Air conditioner compressor regulating valve V135 - Particulate filter additive pump (Only American markets) V157 - Intake manifold flap motor V275 - Intake manifold flap 2 motor V280 - Turbocharger 1 control motor V281 - Turbocharger 2 control motor |
| 12 | 5 | J179 - Automatic glow period control unit J445 - Fuel cooling pump relay J496 - Additional coolant pump relay J703 - Glow period control unit 2 |
| 13 | 25 (Not American markets) 30 | G6 - Fuel system pressurisation pump G23 - Fuel pump J17 - Fuel pump relay J715 - Tank circuit pressurisation relay (Not American markets) |
| 14 | - | Not assigned |
| 15 | 10 | J317 - Terminal 30 voltage supply relay |
| 16 | 10 | J581 - Battery parallel circuit relay |
| 17 | 20 | G39 - Lambda probe G108 - Lambda probe 2 Z19 - Lambda probe heater Z28 - Lambda probe heater 2 |
| 18 | - | Not assigned |
| Relays | ||
| A1 | Glow period control unit 2 -J703- (475) | |
| A2 | Terminal 30 voltage supply relay 2 -J689- (219) | |
| A3 | Automatic glow period control unit -J179- (475) | |
| A4 | Not assigned | |
| A5 | Additional coolant pump relay -J496- (404) | |
| A6 | Fuel cooling pump relay -J445- (404) | |
| B1 | Terminal 30 voltage supply relay -J317- (219) | |
| B2 | Fuel pump relay -J17- (53) | |
| B3 | Not assigned | |
| B3 | Not assigned | |
| B4 | Voltage supply relay 1-J701- (100) / (370) optional installation | |
| B5 | Not assigned | |
| B6 | Not assigned | |
| C19 | Tank circuit pressurisation relay -J715- (404) (Not for American markets) | |
| C20 | Terminal 50 voltage supply relay -J682- (433) |
Engine compartment (3.2L (V6) petrol engine)
Advertisements
Assignment of the fuses in the Engine compartment (3.2L (V6) petrol engine)
| № | A | Function/component |
|---|---|---|
| 1 | 60 | J293 - Radiator fan control unit |
| 2 | 30 | J671 - Radiator fan control unit 2 |
| 3 | 40 | V101 - Secondary air pump motor |
| 4 | - | Not assigned |
| 5 | - | Not assigned |
| 6 | - | Not assigned |
| 7 | 20 | N30 - Injector, cylinder 1 N31 - Injector, cylinder 2 N32 - Injector, cylinder 3 N70 - Ignition coil 1 with power output stage N127 - Ignition coil 2 with power output stage N291 - Ignition coil 3 with power output stage |
| 8 | 20 | N33 - Injector, cylinder 4 N83 - Injector, cylinder 5 N84 - Injector, cylinder 6 N292 - Ignition coil 4 with power output stage N323 - Ignition coil 5 with power output stage N324 - Ignition coil 6 with power output stage |
| 9 | 30 | J220 - Motronic control unit N156 - Variable intake manifold changeover valve N205 - Inlet camshaft control valve 1 N318 - Exhaust camshaft control valve 1 |
| 10 | 10 | G65 - High-pressure sender J293 - Radiator fan control unit J569 - Brake servo relay J671 - Radiator fan control unit 2 N80 - Activated charcoal filter solenoid valve 1 N115 - Activated charcoal filter solenoid valve 2 V144 - Fuel system diagnostic pump |
| 11 | 15 | G266 - Oil level and oil temperature sender J255 - Climatronic control unit N280 - Air conditioner compressor regulating valve |
| 12 | 5 | J299 - Secondary air pump relay J496 - Additional coolant pump relay |
| 13 | 15 | G23 - Fuel pump |
| 14 | 15 | G6 - Fuel system pressurisation pump |
| 15 | 10 | J17 - Fuel pump relay J49 - Electric fuel pump 2 relay J220 - Motronic control unit J271 - Motronic current supply relay J670 - Motronic current supply relay 2 |
| 16 | 15 | V192 - Vacuum pump for brakes |
| 17 | 15 | G39 - Lambda probe G108 - Lambda probe 2 |
| 18 | 7.5 | G130 - Lambda probe after catalytic converter G131 - Lambda probe 2 after catalytic converter |
| Relays | ||
| A1 | Terminal 30 voltage supply relay 2 -J689- (53) | |
| A2 | Not assigned | |
| A3 | Terminal 30 voltage supply relay -J317- (167 | |
| A4 | Secondary air pump relay -J299- (100) / (370) optional installation | |
| A5 | Additional coolant pump relay -J496- (404) | |
| A6 | Fuel pump relay -J17- (53) | |
| B1 | Not assigned | |
| B2 | Not assigned | |
| B3 | Not assigned | |
| B3 | Not assigned | |
| B4 | Not assigned | |
| B5 | Not assigned | |
| B6 | Brake servo relay -J569- (404) (Only models with automatic gearbox) | |
| C19 | Electric fuel pump 2 relay -J49- (404) | |
| C20 | Terminal 50 voltage supply relay -J682- (433) |
Advertisements
Engine compartment (3.6L (V6) FSI engine)
| № | A | Function/component |
|---|---|---|
| 1 | 60 | J293 - Radiator fan control unit |
| 2 | 30 (Only models for tropical climate zones and models with towing coupling) | J671 - Radiator fan control unit 2 V7 - Radiator fan |
| 3 | - | Not assigned |
| 4 | - | Not assigned |
| 5 | - | Not assigned |
| 6 | - | Not assigned |
| 7 | 20 | N70 - Ignition coil 1 with output stage N127 - Ignition coil 2 with output stage N291 - Ignition coil 3 with output stage |
| 8 | 20 | N292 - Ignition coil 4 with output stage N323 - Ignition coil 5 with output stage N324 - Ignition coil 6 with output stage |
| 9 | 30 | J623 - Engine control unit |
| 10 | 10 | G65 - High-pressure sender J293 - Radiator fan control unit J496 - Additional coolant pump relay J671 - Radiator fan control unit 2 (Only models for tropical climate zones and models with towing coupling) V144 - Fuel system diagnostic pump |
| 11 | 10 | J255 - Climatronic control unit J301 - Air conditioning system control unit J442 - Alternator cut-in relay2) N280 - Air conditioner compressor regulating valve |
| 12 | 10 | N80 - Activated charcoal filter system solenoid valve 1 N205 - Inlet camshaft control valve 1 N316 - Intake manifold flap valve N318 - Exhaust camshaft control valve 1 |
| 13 | 25 | J538 - Fuel pump control unit |
| 14 | 15 | N276 - Fuel pressure regulating valve |
| 15 | 10 | J623 - Engine control unit J271 - Motronic current supply relay J670 - Motronic current supply relay 2 |
| 16 | 15 | J496 - Additional coolant pump relay |
| 17 | 15 | G39 - Lambda probe G108 - Lambda probe 2 Z19 - Lambda probe heater Z28 - Lambda probe heater 2 |
| 18 | 7.5 | G130 - Lambda probe after catalytic converter G131 - Lambda probe 2 after catalytic converter Z29 - Lambda probe 1 heater after catalytic converter Z30 - Lambda probe 2 heater after catalytic converter |
| Relays | ||
| A1 | Not assigned | |
| A2 | Not assigned | |
| A3 | Motronic current supply relay -J271- (614) | |
| A4 | Not assigned | |
| A5 | Additional coolant pump relay -J496- (404) | |
| A6 | Not assigned | |
| B1 | Not assigned | |
| B2 | Not assigned | |
| B3 | Not assigned | |
| B3 | Not assigned | |
| B4 | Motronic current supply relay 2 -J670- (614) to May 2007 | |
| B5 | Not assigned | |
| B6 | Not assigned | |
| C19 | Not assigned | |
| C20 | Terminal 50 voltage supply relay -J682- (433) |
Advertisements
Engine compartment (4.2L (V8) FSI engine)
| № | A | Function/component |
|---|---|---|
| 1 | 60 | J671 - Radiator fan control unit 2 V177 - Radiator fan 2 |
| 2 | 60 (Only models with towing coupling) 30 | J293 - Radiator fan control unit V7 - Radiator fan |
| 3 | 40 | J299 - Secondary air pump relay V101 - Secondary air pump motor |
| 4 | - | Not assigned |
| 5 | - | Not assigned |
| 6 | - | Not assigned |
| 7 | 20 | N70 - Ignition coil 1 with output stage N127 - Ignition coil 2 with output stage N291 - Ignition coil 3 with output stage N292 - Ignition coil 4 with output stage N323 - Ignition coil 5 with output stage N324 - Ignition coil 6 with output stage N325 - Ignition coil 7 with output stage N326 - Ignition coil 8 with output stage |
| 8 | - | Not assigned |
| 9 | 30 | J623 - Engine control unit |
| 10 | 10 | G70 - Air mass meter G246 - Air mass meter 2 J299 - Secondary air pump relay N80 - Activated charcoal filter solenoid valve 1 V144 - Fuel system diagnostic pump |
| 11 | - | Not assigned |
| 12 | 20 | F265 - Map-controlled engine cooling system thermostat G65 - High-pressure sender J151 - Continued coolant circulation relay J255 - Climatronic control unit J301 - Air conditioning system control unit J293 - Radiator fan control unit J442 - Alternator cut-in relay (Up to May 2007) J671 - Radiator fan control unit 2 N205 - Inlet camshaft control valve 1 N208 - Inlet camshaft control valve 2 N280 - Air conditioner compressor regulating valve N318 - Exhaust camshaft control valve 1 N319 - Exhaust camshaft control valve 2 V157 - Intake manifold flap motor V183 - Variable intake manifold motor |
| 13 | 25 | J538 - Fuel pump control unit |
| 14 | 10 | N290 - Fuel metering valve N402 - Fuel metering valve 2 |
| 15 | 10 | J271 - Motronic current supply relay J623 - Engine control unit |
| 16 | 15 | J569 - Brake servo relay V192 - Vacuum pump for brakes |
| 17 | 10 | G39 - Lambda probe G108 - Lambda probe 2 |
| 18 | 10 | G130 - Lambda probe after catalytic converter G131 - Lambda probe 2 after catalytic converter |
| Relays | ||
| A1 | Not assigned | |
| A2 | Not assigned | |
| A3 | Automatic glow period control unit -J179- (475) | |
| A4 | Secondary air pump relay -J299- (100) / (370) optional installation | |
| A5 | Continued coolant circulation relay -J151- (404) | |
| A6 | Not assigned | |
| B1 | Not assigned | |
| B2 | Not assigned | |
| B3 | Not assigned | |
| B3 | Not assigned | |
| B4 | Engine components current supply relay -J757- (614) | |
| B5 | Not assigned | |
| B6 | Brake servo relay -J569- (404) (Only models with automatic gearbox) | |
| C19 | Not assigned | |
| C20 | Terminal 50 voltage supply relay -J682- (433) |
Advertisements
Engine compartment (6.0L (W12) petrol engine)
| № | A | Function/component |
|---|---|---|
| 1 | 60 | J671 - Radiator fan control unit 2 V177 - Radiator fan 2 |
| 2 | 60 (Only models with towing coupling) 30 | J293 - Radiator fan control unit V7 - Radiator fan |
| 3 | 40 | J299 - Secondary air pump relay V101 - Secondary air pump motor |
| 4 | 40 | J545 - Secondary air pump relay 2 V189 - Secondary air pump motor 2 |
| 5 | 30 | N325 - Ignition coil 7 with output stage N326 - Ignition coil 8 with output stage N327 - Ignition coil 9 with output stage N328 - Ignition coil 10 with output stage N329 - Ignition coil 11 with output stage N330 - Ignition coil 12 with output stage S7 - Fuse in relay plate fuse holder |
| 6 | 30 | N70 - Ignition coil 1 with output stage N127 - Ignition coil 2 with output stage N291 - Ignition coil 3 with output stage N292 - Ignition coil 4 with output stage N323 - Ignition coil 5 with output stage N324 - Ignition coil 6 with output stage S8 - Fuse in relay plate fuse holder |
| 7 | 10 | N85 - Injector, cylinder 7 N86 - Injector, cylinder 8 N299 - Injector, cylinder 9 N300 - Injector, cylinder 10 N301 - Injector, cylinder 11 N302 - Injector, cylinder 12 |
| 8 | 10 | N30 - Injector, cylinder 1 N31 - Injector, cylinder 2 N32 - Injector, cylinder 3 N33 - Injector, cylinder 4 N83 - Injector, cylinder 5 N84 - Injector, cylinder 6 |
| 9 | 30 | J623 - Engine control unit J624 - Engine control unit 2 |
| 10 | 10 | G65 - High-pressure sender J255 - Climatronic control unit J293 - Radiator fan control unit J301 - Air conditioning system control unit J442 - Alternator cut-in relay (Up to May 2007) J671 - Radiator fan control unit 2 V144 - Fuel system diagnostic pump |
| 11 | 15 | N80 - Activated charcoal filter solenoid valve 1 N205 - Inlet camshaft control valve 1 N208 - Inlet camshaft control valve 2 N280 - Air conditioner compressor regulating valve N318 - Exhaust camshaft control valve 1 N319 - Exhaust camshaft control valve 2 |
| 12 | 5 | J49 - Electric fuel pump 2 relay J299 - Secondary air pump relay J545 - Secondary air pump relay 2 J624 - Engine control unit 2 |
| 13 | 15 | G6 - Fuel system pressurisation pump J17 - Fuel pump relay |
| 14 | 15 | G23 - Fuel pump J49 - Electric fuel pump 2 relay |
| 15 | 10 | J17 - Fuel pump relay J271 - Motronic current supply relay J623 - Engine control unit J624 - Engine control unit 2 |
| 16 | 15 | J496 - Additional coolant pump relay J569 - Brake servo relay V51 - Continued coolant circulation pump V192 - Vacuum pump for brakes |
| 17 | 30 | G39 - Lambda probe G108 - Lambda probe 2 G285 - Lambda probe 3 G286 - Lambda probe 4 Z19 - Lambda probe heater Z28 - Lambda probe heater 2 Z62 - Lambda probe heater 3 Z63 - Lambda probe heater 4 |
| 18 | 15 | G130 - Lambda probe after catalytic converter G131 - Lambda probe 2 after catalytic converter G287 - Lambda probe 3 after catalytic converter G288 - Lambda probe 4 after catalytic converter Z29 - Lambda probe 1 heater after catalytic converter Z30 - Lambda probe 2 heater after catalytic converter Z64 - Lambda probe 3 heater after catalytic converter Z65 - Lambda probe 4 heater after catalytic converter |
| Relays | ||
| A1 | Not assigned | |
| A2 | Not assigned | |
| A3 | Motronic current supply relay -J271- (100) / (370) optional installation | |
| A4 | Secondary air pump relay -J299- (100) / (370) optional installation | |
| A5 | Additional coolant pump relay -J496- (404) | |
| A6 | Electric fuel pump 2 relay -J49- (404) | |
| B1 | Not assigned | |
| B2 | Not assigned | |
| B3 | Not assigned | |
| B3 | Secondary air pump relay 2 -J545- (100) / (370) optional installation | |
| B4 | Not assigned | |
| B5 | Not assigned | |
| B6 | Brake servo relay -J569- (404) (Only models with automatic gearbox) | |
| C19 | Fuel pump relay -J17- (404) | |
| C20 | Terminal 50 voltage supply relay -J682- (433) |
Pre-fuse box
| № | A | Function/component |
|---|---|---|
| SD1 | 150 | Left fuse carrier |
| SD2 | 150 | Right fuse carrier |
| SD3 | 60 | Right fuse carrier |
| SD4 | 60 40 (From November 2007) | J701 - Voltage supply relay 2 (Only V10 TDI) V306 - Motor for rear Bitron blower regulation (From November 2007) |
| SD5 | 60 40 (From November 2007) | J329 - Terminal 15 voltage supply relay |
| SD6 | - | Not assigned |
| SD7 | 250 | J713 - Charger relay for second battery |
| SD8 | 150 (Only V10 TDI) 60 (Only models with additional battery) | Left fuse carrier J701 - Voltage supply relay 1 (Only V10 TDI) |
| SD9 | 5 | J519 - Onboard supply control unit |
| SD10 | 10 5 (From November 2007) | J519 - Onboard supply control unit (Only V10 TDI) |
| SD11 | 5 | J519 - Onboard supply control unit (Only V10 TDI) |
| SD12 | - | Not assigned |
| SD13 | 40 | J403 - Adaptive suspension compressor relay V306 - Motor for rear Bitron blower regulation (Only V10 TDI) (From November 2007) |
| SD14 | - | Not assigned |
| Relays | ||
| 1 | Battery master/isolator switch -E74- | |
| 2 | Terminal 15 voltage supply relay -J329- (433) | |
| 3 | Second battery charging circuit relay -J713- |
Advertisements
Relay panel E-Box 1
| № | Function/component |
|---|---|
| D1 | Servotronic control unit -J236- (476) |
| D2 | Power latching system relay -J714- (404) |
| D3 | Adaptive suspension compressor relay -J403- (373) |
| D4 | Power sockets relay -J807- (404) |
| D5 | Air conditioning system relay -J32- (100) / (370) optional installation |
| D6 | Fresh air blower relay, 2nd speed -J486- (404), only manually operated air conditioning system |
| D7 | Heated rear window relay -J9- (53) |
| D8 | Circulation pump relay -J160- (404), only VR6 with auxiliary heater |
| D9 | Alternator cut-in relay -J442- (53) |
| E1 | Solar cells isolation relay -J309- (79) |
| E2 | Not assigned |
| E3 | Heated windscreen relay for left side -J410- (53) |
| E4 | Not assigned |
| E5 | Voltage supply relay 2 -J710- (432), only V10 TDI |
| E6 | Not assigned |
| E7 | Headlight washer system relay -J39- (53) |
| E8 | Residual heat relay -J708- (404) |
| E9 | Heated windscreen relay for right side -J411- (53) |
Relay panel E-box 2
| № | Function/component |
|---|---|
| D1 | Servotronic control unit -J236- (476) |
| D2 | Power latching system relay -J714- (404) |
| D3 | Adaptive suspension compressor relay -J403- (373) |
| D4 | Power sockets relay -J807- (404) |
| D5 | Air conditioning system relay -J32- (100) / (370) optional installation |
| D6 | Fresh air blower relay, 2nd speed -J486- (404), only manually operated air conditioning system |
| D7 | Heated rear window relay -J9- (53) |
| D8 | Circulation pump relay -J160- (404), only VR6 with auxiliary heater |
| D9 | Alternator cut-in relay -J442- (53) |
| E1 | Solar cells isolation relay -J309- (79) |
| E2 | Residual heat relay -J708- (404) |
| E3 | Heated windscreen relay for left side -J410- (53) |
| E4 | Voltage supply relay 2 -J710- (432), only V10 TDI |
| E5 | Heated windscreen relay for right side -J411- (53) |
| E6 | Headlight washer system relay -J39- (53) |
Advertisements