Advertisements
The small family car Volvo V40 was produced from 2012 to 2019. In this article, you will find fuse box diagrams of Volvo V40 2013, 2014, 2015, 2016, 2017, 2018 and 2019, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout).
Fuse Layout Volvo V40 2013-2019
Cigar lighter (power outlet) fuses in the Volvo V40 are the fuses #25 (12 V socket, tunnel console front), #28 (12 V socket, tunnel console rear) in the engine compartment fuse box, and fuse #17 (12 V socket, cargo area) in the fuse box under the seat.
Table of Contents
Fuse box location
Fuse box location
1) Engine compartment
2) Under the glovebox
- Take hold of the recess and pull until the locking lugs in the lower edge of the cover are released from the fusebox.
- Remove the cover
In a right-hand drive car the fuse box under the glovebox changes sides.
3) Under the right-hand front seat
Fuse box diagrams
Fuse box diagrams
Advertisements
2013
Engine compartment
| № | Function | Amp |
|---|---|---|
| 7 | ABS pump | 40 |
| 8 | ABS valves | 30 |
| 9 | Headlamp washers (option) | 20 |
| 10 | Ventilation fan | 40 |
| 11 | - | - |
| 12 | Primary fuse for fuses 32-36 | 30 |
| 13 | Starter motor actuator solenoid (not Start/Stop) | 30 |
| 14 | Electric windscreen, right side (option) | 40 |
| 15 | ||
| 16 | Electric windscreen, left side (option) | 40 |
| 17 | Parking heater (option) | 20 |
| 18 | Windscreen wipers | 20 |
| 19 | Central electronic module, reference voltage, standby battery (Start/Stop) | 5 |
| 20 | Horn | 15 |
| 21 | Brake light | 5 |
| 22 | ||
| 23 | Headlamp control | 5 |
| 24 | Internal relay coils | 5 |
| 25 | 12 V socket, tunnel console front | 15 |
| 26 | Transmission control module | 15 |
| 27 | Solenoid clutch A/C | 15 |
| 28 | 12 V socket, tunnel console rear | 15 |
| 29 | Climate sensor (option); air intake throttle motors | 10 |
| 30 | Engine control module (5-cyl.) | 5 |
| 31 | Power seat, right (option) | 20 |
| 32 | Relay coil in cooling fan relay (4-cyl., 5-cyl. diesel); Lambda-sonds (4-cyl. petrol); Mass air flow meter (diesel), Bypass valve, EGR cooling (diesel); Regulator valve, fuel flow (5-cyl. diesel); Regulator valve, fuel pressure (5-cyl. diesel) | 10 |
| 32 | Relay coil in cooling fan relay (5- cyl. petrol); Lambda-sonds (5- cyl. petrol) | 20 |
| 33 | Mass air flow meter (4-cyl. petrol); EVAP valve (4-cyl. petrol); Injection valves (5-cyl. petrol); Control motor, turbo (4-cyl. diesel); Regulator valve, fuel flow (4- cyl. diesel); Solenoid, piston cooling (5-cyl. diesel); Turbo regulator valve (5-cyl. diesel); Oil level sensor (5-cyl. diesel) | 10 |
| 34 | Valves (petrol); Solenoids (petrol); Lambda probe (diesel); Crankcase ventilation heater (5-cyl.); Mass air flow meter (5-cyl. petrol) | 10 |
| 35 | Ignition coils (petrol) | 10 |
| 35 | Diesel filter heater; Glow plug control unit (5-cyl. diesel); Oil pump, automatic gearbox (5-cyl. diesel Start/Stop) | 15 |
| 36 | Engine control module (4-cyl.) | 10 |
| 36 | Engine control module (5-cyl.); Throttle unit (5-cyl. petrol) | 15 |
| 37 | ABS | 5 |
| 38 | Engine control module; Transmission control module; Airbags | 10 |
| 39 | Light height control (option) | 10 |
| 40 | Electric control servo | 5 |
| 41 | Central electronic module | 15 |
| 42 | ||
| 43 | Coolant pump (Start/Stop) | 10 |
| 44 | Collision warning system | 5 |
| 45 | Accelerator pedal sensor | 5 |
| 46 | Charging point, standby battery | - |
| 47 | ||
| 48 |
Fuses 7-18 are of “JCASE” type and should be replaced by a workshop.
Fuses 19-45 and 47-48 are of “Mini Fuse” type
Fuses 19-45 and 47-48 are of “Mini Fuse” type
Advertisements
Under the glovebox
| № | Function | Amp |
|---|---|---|
| 56 | Fuel pump | 20 |
| 57 | - | - |
| 58 | Rear window wiper | 15 |
| 59 | Reserve position, interior lighting | 5 |
| 60 | Interior lighting; Power seats | 10 |
| 61 | Blind, glass roof (option) | 10 |
| 62 | Rain sensor (option); Dimming, interior rearview mirror (option); Moisture sensor (option) | 5 |
| 63 | Collision warning system (option) | 5 |
| 64 | - | - |
| 65 | Unlocking, tailgate (See also fuse 84) | 10 |
| 66 | ||
| 67 | Reserve position 3, constant voltage | 5 |
| 68 | Steering lock | 15 |
| 69 | Combined instrument panel | 5 |
| 70 | Central locking system, fuel filler flap (See also fuse 83) | 10 |
| 71 | Climate panel | 10 |
| 72 | Steering wheel module | 7.5 |
| 73 | Siren alarm (option); Data link connector OBDII | 5 |
| 74 | Main beam | 15 |
| 75 | ||
| 76 | Reversing lamp | 10 |
| 77 | Windscreen wipers (See also fuse 82); Rear windscreen wiper (See also fuse 82) | 20 |
| 78 | Immobiliser | 5 |
| 79 | Reserve position 1, constant voltage | 15 |
| 80 | Reserve position 2, constant voltage | 20 |
| 81 | Movement sensor alarm (option); Remote receiver | 5 |
| 82 | Windscreen wipers (See also fuse 77); Rear windscreen wiper (See also fuse 77) | 20 |
| 83 | Central locking system, fuel filler flap (See also fuse 70) | 10 |
| 84 | Unlocking, tailgate (See also fuse 65) | 10 |
| 85 | PTC element, air preheater (option); Button, rear seat heating (option) | 7.5 |
| 86 | Airbags; Pedestrian airbag | 10 |
| 87 | Reserve position 4, constant voltage | 7.5 |
| 88 | ||
| 89 |
Advertisements
Under the seat
| № | Function | Amp |
|---|---|---|
| 1 | ||
| 2 | Keyless (option) | 10 |
| 3 | Door handle (Keyless (option)) | 5 |
| 4 | Control panel, left front door | 25 |
| 5 | Control panel, right front door | 25 |
| 6 | Control panel, left rear door | 25 |
| 7 | Control panel, right rear door | 25 |
| 8 | - | - |
| 9 | Power seat left (option) | 20 |
| 10 | - | - |
| 11 | - | - |
| 12 | Audio control unit (amplifier) (option) | 5 |
| 13 | - | - |
| 14 | Telematics (option); Bluetooth (option) | 5 |
| 15 | Audio; Infotainment control unit | 15 |
| 16 | Digital radio (option); TV (option) | 10 |
| 17 | 12 V socket, cargo area | 15 |
| 18 | - | - |
| 19 | - | - |
| 20 | - | - |
| 21 | - | - |
| 22 | - | - |
| 23 | Trailer socket 2 (option) | 20 |
| 24 | Primary fuse for fuses 12-16; Infotainment | 40 |
| 25 | - | - |
| 26 | Trailer socket 1 (option) | 40 |
| 27 | Rear window defroster | 30 |
| 28 | - | - |
| 29 | BLIS (option) | 5 |
| 30 | Parking assistance (option) | 5 |
| 31 | Parking camera (option) | 5 |
| 32 | - | - |
| 33 | - | - |
| 34 | Seat heating (driver's side) | 15 |
| 35 | Seat heating (passenger side) | 15 |
| 36 | - | - |
| 37 | - | - |
| 38 | - | - |
| 39 | Seat heating, rear right (option) | 15 |
| 40 | Seat heating, rear left (option) | 15 |
| 41 | AWD control module (option) | 15 |
| 42 | - | - |
| 43 | - | - |
| 44 | - | - |
| 45 | - | - |
| 46 | - | - |
Fuses 24-28 are of “JCASE” type and should be replaced by a workshop.
Fuses 1-23 and 29-46 are of “Mini Fuse” type.
Fuses 1-23 and 29-46 are of “Mini Fuse” type.
2015
Engine compartment
Advertisements
Assignment of fuses in the engine compartment (2015)
| № | Function | Amp |
|---|---|---|
| 7 | ABS pump | 40 |
| 8 | ABS valves | 30 |
| 9 | Headlamp washers (option) | 20 |
| 10 | Ventilation fan | 40 |
| 11 | - | - |
| 12 | Primary fuse for fuses 32-36 | 30 |
| 13 | - | - |
| 14 | Heated windscreen, right-hand side (option) | 40 |
| 15 | - | - |
| 16 | Heated windscreen, left-hand side (option) | 40 |
| 17 | Parking heater (option) | 20 |
| 18 | Windscreen wipers | 20 |
| 19 | Central electronic module, reference voltage, standby battery (Start/Stop) | 5 |
| 20 | Horn | 15 |
| 21 | Brake light | 5 |
| 22 | - | - |
| 23 | Headlamp control | 5 |
| 24 | Internal relay coils | 5 |
| 25 | 12 V socket, tunnel console front | 15 |
| 26 | Transmission control module | 15 |
| 27 | Solenoid clutch A/C (1.6 litre, 5- cyl. petrol) | 15 |
| 28 | 12 V socket, tunnel console rear | 15 |
| 29 | - | - |
| 30 | Engine control module (4-cyl. 2.0 l, 5-cyl.) | 5 |
| 31 | Power seat, right (option) | 20 |
| 32 | Relay coil in cooling fan relay (4-cyl. 1.6 l, 5-cyl. diesel); Lambda-sonds (4-cyl. 1.6 l petrol); Mass air flow meter (1.6 l diesel, 5-cyl. diesel), Bypass valve, EGR cooling (1.6 l diesel); Bypass solenoid EGR cooling (5-cyl. diesel); Regulator valve, fuel flow (5-cyl. diesel); Regulator valve, fuel pressure (5-cyl. diesel) | 10 |
| 32 | Lambda sonds (4-cyl. 2.0 l); Relay coil in relay for cooling fan (4-cyl. 2.0 l) | 15 |
| 32 | Relay coil in cooling fan relay (5-cyl. petrol); Lambda-sonds (5-cyl. petrol) | 20 |
| 32 | Relay coil in cooling fan relay (5- cyl. petrol); Lambda-sonds (5- cyl. petrol) | 20 |
| 33 | Oil pump automatic gearbox (5-cyl.); Mass air flow sensor (1.6 l petrol, 5-cyl. petrol); EVAP valve (1.6 l petrol); Valves (4 cyl. 2.0 l 5-cyl. petrol); Solenoids (5- cyl. petrol); Crankcase ventilation heater (5-cyl. petrol); Control motor turbo (1.6 l diesel); Regulator valve, fuel flow (1.6 l diesel); Control module radiator roller cover (1.6 l diesel); Solenoid piston cooling (5-cyl. diesel); Turbo control valve (5-cyl. diesel); Oil level sensor (5-cyl. diesel); Compressor A/C (4-cyl. 2.0 l 5-cyl. diesel); Oil pump (4- cyl. 2.0 l); Cooling valve for climate control system (4-cyl. 2.0 l diesel); Relay coils in relays for Start/Stop functions | 10 |
| 34 | Valves (1.6 l petrol); Solenoids (1.6 l petrol); Injectors (5-cyl. petrol); Lambda-sond (5-cyl. diesel); Crankcase ventilation heater (5-cyl. diesel) | 10 |
| 34 | Valve (4-cyl 2.0 l diesel); EVAP valve (4-cyl. 2.0 l petrol); Crankcase ventilation heater (4 cyl. 2.0 l petrol); Engine control module (4-cyl. 2.0 l), Mass air flow sensor (4-cyl. 2.0 l); Thermostat (4-cyl. 2.0 l petrol); Cooling pump for EGR (4 cyl. 2.0 l diesel); Glow control module (4-cyl. 2.0 l diesel) | 15 |
| 35 | Ignition coils (1.6 l petrol, 5-cyl. petrol) | 10 |
| 35 | Ignition coils (4-cyl. 2.0 l petrol); Diesel filter heater (1.6 l diesel, 5-cyl. diesel); Glow control module (5-cyl. diesel) | 15 |
| 35 | Diesel filter heater (4-cyl. 2.0 l diesel) | 25 |
| 36 | Engine control module (1.6 l) | 10 |
| 36 | Engine control module (4-cyl. 2.0 l, 5-cyl.); Throttle unit (5-cyl. petrol) | 15 |
| 37 | ABS | 5 |
| 38 | Engine control module; Transmission control module; Airbags | 10 |
| 39 | Headlamp levelling (option) | 10 |
| 40 | Electric control servo | 5 |
| 41 | Central electronic module | 15 |
| 42 | - | - |
| 43 | - | - |
| 44 | Collision warning system | 5 |
| 45 | Accelerator pedal sensor | 5 |
| 46 | Charging point, standby battery | - |
| 47 | - | - |
| 48 | Coolant pump (when no parking heater is available) | 10 |
Fuses 7-18 are of “JCASE” type and should be replaced by a workshop.
Fuses 19-45 and 47-48 are of “Mini Fuse” type.
Fuses 19-45 and 47-48 are of “Mini Fuse” type.
Advertisements
Under the glovebox
| № | Function | Amp |
|---|---|---|
| 56 | Fuel pump | 20 |
| 57 | - | - |
| 58 | Rear window wiper | 15 |
| 59 | Display in roof console (Seatbelt reminder/Indicator for airbag on the front passenger seat) | 5 |
| 60 | Interior lighting, Controls in roof console for front reading lamps and passenger compartment lighting; Power seats (option) | 7.5 |
| 61 | Power operated roller blind, glass roof (option) | 10 |
| 62 | Rain sensor (option); Dimming, interior rearview mirror (option); Moisture sensor (option) | 5 |
| 63 | Collision warning system (option) | 5 |
| 64 | - | - |
| 65 | Unlocking, tailgate (See also fuse 84) | 10 |
| 66 | ||
| 67 | Reserve position 3, constant voltage | 5 |
| 68 | Steering lock | 15 |
| 69 | Combined instrument panel | 5 |
| 70 | Central locking system, fuel filler flap (See also fuse 83) | 10 |
| 71 | Climate panel | 10 |
| 72 | Steering wheel module | 7.5 |
| 73 | Siren alarm (option); Data link connector OBDII | 5 |
| 74 | Main beam | 15 |
| 75 | ||
| 76 | Reversing lamp | 10 |
| 77 | Windscreen wipers (See also fuse 82); Rear windscreen wiper (See also fuse 82) | 20 |
| 78 | Immobiliser | 5 |
| 79 | Reserve position 1, constant voltage | 15 |
| 80 | Reserve position 2, constant voltage | 20 |
| 81 | Movement sensor alarm (option); Remote receiver | 5 |
| 82 | Windscreen wipers (See also fuse 77); Rear windscreen wiper (See also fuse 77) | 20 |
| 83 | Central locking system, fuel filler flap (See also fuse 70) | 10 |
| 84 | Unlocking, tailgate (See also fuse 65) | 10 |
| 85 | Electric additional heater(option); Button seat heating rear (option) | 7.5 |
| 86 | Airbags; Pedestrian airbag | 7.5 |
| 87 | Reserve position 4, constant voltage | 7.5 |
| 88 | ||
| 89 |
Advertisements
Under the seat
| № | Function | Amp |
|---|---|---|
| 1 | ||
| 2 | Keyless (option) | 10 |
| 3 | Door handle (Keyless (option)) | 5 |
| 4 | Control panel, left front door | 25 |
| 5 | Control panel, right front door | 25 |
| 6 | Control panel, left rear door | 25 |
| 7 | Control panel, right rear door | 25 |
| 8 | Primary fuse for fuses 12-16: Infotainment | 25 |
| 9 | Power seat, left (option) | 20 |
| 10 | ||
| 11 | Internal relay coil | 5 |
| 12 | Audio control unit (amplifier) (option), signal for diagnosis | 5 |
| 13 | ||
| 14 | Telematics (option); Bluetooth (option) | 5 |
| 15 | Audio control module or Control module Sensus A ; Infotainment control module or Screen A | 15 |
| 16 | Digital radio (option); TV (option) | 7.5 |
| 17 | 12 V socket, cargo area | 15 |
| 18 | ||
| 19 | ||
| 20 | ||
| 21 | ||
| 22 | ||
| 23 | Trailer socket 2 (option) | 20 |
| 24 | Audio control unit (amplifier) (option) | 30 |
| 25 | - | - |
| 26 | Trailer socket 1 (option) | 40 |
| 27 | Rear window defroster | 30 |
| 28 | ||
| 29 | BLIS (option) | 5 |
| 30 | Parking assistance (option) | 5 |
| 31 | Parking camera (option) | 5 |
| 32 | ||
| 33 | ||
| 34 | Seat heating, front driver's side | 15 |
| 35 | Seat heating, front passenger side | 15 |
| 36 | ||
| 37 | ||
| 38 | ||
| 39 | Seat heating, rear right (option) | 15 |
| 40 | Seat heating, rear left (option) | 15 |
| 41 | ||
| 42 | ||
| 43 | ||
| 44 | ||
| 45 | ||
| 46 |
Fuses 24-28 are of “JCASE” type and should be replaced by a workshop.
Fuses 1-23 and 29-46 are of “Mini Fuse” type.
Fuses 1-23 and 29-46 are of “Mini Fuse” type.
2016, 2017, 2018, 2019
Engine compartment
Advertisements
Assignment of fuses in the engine compartment (2016, 2017, 2018, 2019)
| № | Function | Amp |
|---|---|---|
| 7 | ABS pump | 40 |
| 8 | ABS valves | 30 |
| 9 | Headlamp washers (option) | 20 |
| 10 | Ventilation fan | 40 |
| 11 | - | - |
| 12 | Primary fuse for fuses 32-36 | 30 |
| 13 | - | - |
| 14 | Heated windscreen, right-hand side (option) | 40 |
| 15 | - | - |
| 16 | Heated windscreen, left-hand side (option) | 40 |
| 17 | Parking heater (option) | 20 |
| 18 | Windscreen wipers | 20 |
| 19 | Central electronic module, reference voltage, standby battery (Start/Stop) | 5 |
| 20 | Horn | 15 |
| 21 | Brake light | 5 |
| 22 | - | - |
| 23 | Headlamp control | 5 |
| 24 | Internal relay coils | 5 |
| 25 | 12 V socket, tunnel console front | 15 |
| 26 | Transmission control module | 15 |
| 27 | ||
| 28 | 12 V socket, tunnel console rear | 15 |
| 29 | - | - |
| 30 | Engine Control Module (ECM) | 5 |
| 31 | Power seat, right (option) | 20 |
| 32 | Lambda-sonds; Relay coil in relay for cooling fan | 15 |
| 33 | Vacuum regulators; Valves; Control module, radiator roller cover; Control module, spoiler roller cover (diesel); Compressor A/C; Solenoid for engine oil pump; Cooling valve for climate control system (diesel); Glow control module (diesel); Relay coils in relays for Start/Stop functions | 10 |
| 34 | EGR valve (diesel); EVAP valve (petrol); Engine control module; Thermostat for engine cooling system (petrol); Cooling pump for EGR (diesel) | 15 |
| 35 | Ignition coils (petrol) | 15 |
| 35 | Diesel filter heater (diesel) | 25 |
| 36 | Engine Control Module (ECM) | 15 |
| 37 | ABS | 5 |
| 38 | Engine control module; Transmission control module; Airbags | 10 |
| 39 | Headlamp levelling (option) | 10 |
| 40 | Electric control servo | 5 |
| 41 | Central electronic module | 15 |
| 42 | - | - |
| 43 | - | - |
| 44 | Collision warning system | 5 |
| 45 | Accelerator pedal sensor | 5 |
| 46 | - | |
| 47 | - | - |
| 48 | Coolant pump (when no parking heater is available) | 10 |
Fuses 7-18 are of “JCASE” type and should be replaced by a workshop.
Fuses 19-45 and 47-48 are of “Mini Fuse” type.
Fuses 19-45 and 47-48 are of “Mini Fuse” type.
Advertisements
Under the glovebox
| № | Function | Amp |
|---|---|---|
| 56 | Fuel pump | 20 |
| 57 | - | - |
| 58 | Rear window wiper | 15 |
| 59 | Display in roof console (Seatbelt reminder/Indicator for airbag on the front passenger seat) | 5 |
| 60 | Interior lighting, Controls in roof console for front reading lamps and passenger compartment lighting; Power seats (option) | 7.5 |
| 61 | Power operated roller blind, glass roof (option) | 10 |
| 62 | Rain sensor (option); Dimming, interior rearview mirror (option); Moisture sensor (option) | 5 |
| 63 | Collision warning system (option) | 5 |
| 64 | - | - |
| 65 | Unlocking, tailgate (See also fuse 84) | 10 |
| 66 | ||
| 67 | Reserve position 3, constant voltage | 5 |
| 68 | Steering lock | 15 |
| 69 | Combined instrument panel | 5 |
| 70 | Central locking system, fuel filler flap (See also fuse 83) | 10 |
| 71 | Climate panel | 10 |
| 72 | Steering wheel module | 7.5 |
| 73 | Siren alarm (option); Data link connector OBDII | 5 |
| 74 | Main beam | 15 |
| 75 | ||
| 76 | Reversing lamp | 10 |
| 77 | Windscreen wipers (See also fuse 82); Rear windscreen wiper (See also fuse 82) | 20 |
| 78 | Immobiliser | 5 |
| 79 | Reserve position 1, constant voltage | 15 |
| 80 | Reserve position 2, constant voltage | 20 |
| 81 | Movement sensor alarm (option); Remote receiver | 5 |
| 82 | Windscreen wipers (See also fuse 77); Rear windscreen wiper (See also fuse 77) | 20 |
| 83 | Central locking system, fuel filler flap (See also fuse 70) | 10 |
| 84 | Unlocking, tailgate (See also fuse 65) | 10 |
| 85 | Electric additional heater(option); Button seat heating rear (option) | 7.5 |
| 86 | Airbags; Pedestrian airbag | 7.5 |
| 87 | Reserve position 4, constant voltage | 7.5 |
| 88 | ||
| 89 |
Advertisements
Under the seat
| № | Function | Amp |
|---|---|---|
| 1 | ||
| 2 | Keyless (option) | 10 |
| 3 | Door handle (Keyless (option)) | 5 |
| 4 | Control panel, left front door | 25 |
| 5 | Control panel, right front door | 25 |
| 6 | Control panel, left rear door | 25 |
| 7 | Control panel, right rear door | 25 |
| 8 | Primary fuse for fuses 12-16: Infotainment | 25 |
| 9 | Power seat, left (option) | 20 |
| 10 | ||
| 11 | Internal relay coil | 5 |
| 12 | ||
| 13 | ||
| 14 | ||
| 15 | ||
| 16 | ||
| 17 | 12 V socket, cargo area | 15 |
| 18 | ||
| 19 | ||
| 20 | ||
| 21 | ||
| 22 | ||
| 23 | Trailer socket 2 (option) | 20 |
| 24 | Audio control unit (amplifier) (option) | 30 |
| 25 | - | - |
| 26 | Trailer socket 1 (option) | 40 |
| 27 | Rear window defroster | 30 |
| 28 | ||
| 29 | BLIS (option) | 5 |
| 30 | Parking assistance (option) | 5 |
| 31 | Parking camera (option) | 5 |
| 32 | ||
| 33 | ||
| 34 | Seat heating, front driver's side | 15 |
| 35 | Seat heating, front passenger side | 15 |
| 36 | ||
| 37 | ||
| 38 | ||
| 39 | Seat heating, rear right (option) | 15 |
| 40 | Seat heating, rear left (option) | 15 |
| 41 | ||
| 42 | ||
| 43 | ||
| 44 | ||
| 45 | Audio control module (amplifier) (option), signal for diagnosis; Audio control module or Control module Sensus (Certain model variants); Infotainment control module or Screen (Certain model variants); Digital radio (option); TV (option) | 15 |
| 46 | Telematics (option); Bluetooth (option) | 5 |
Fuses 24-28 are of “JCASE” type and should be replaced by a workshop.
Fuses 1-23 and 29-46 are of “Mini Fuse” type.
Fuses 1-23 and 29-46 are of “Mini Fuse” type.
Advertisements